Bell-Boeing's V-22 Osprey first took to the air nearly
20 years ago and the road to active duty has been a long one. When DailyTech last visited the tilt-rotor aircraft,
the Air Force's CV-22 Osprey was criticized for its "poor aircraft availability"
and "marginal operational availability" during desert testing at
Kirkland Air Force Base.
"Frequent part and system failures, limited supply
support, and high false alarm rates in the built-in diagnostic systems caused
frequent flight delays and an excessive maintenance workload," claimed the
report which was released earlier this year.
"This produces a maintenance and support burden that
the Marines really can’t afford. All of the reliability problems that they
continue to have here in the [United] States -- it’s going to drive them crazy
overseas," said Philip Coyle, senior advisor for the Center for Defense
Despite the troubles, the U.S. Marines will be deploying
seven of its similar MV-22 Ospreys to Iraq in September. The Marines are
hoping that the Osprey’s speed will allow it to quickly transport troops and make
it less of a target for insurgents than slower, traditional helicopters.
"It is our fervent feeling that this aircraft is the
most capable, survivable aircraft that we carry our most important weapons
system in, which is the Marine or rifleman," said Lt. Gen. John Castellaw,
the deputy commandant for aviation for the Marines. "If you've ever gone
rabbit hunting, you know that it's harder to shoot a rabbit that's running than
the one that's sitting still."
The push for the Osprey to enter regular military service
has been a long time coming. In 2007 alone, there have been six crashes
involving U.S. helicopters in Iraq. The Osprey's enviable speed (top speed
316MPH), ability to take-off and land like a helicopter and an operating range
that is three to five times that of traditional helicopters should make it a
great workhorse during its seven month deployment.
The V-22 Osprey is destined to replace the Marines' CH-46
Sky King by 2018. When compared to the CH-46, the Osprey has a range that is
three times farther and has six to seven times the survivability in the field.
The tilt-rotor aircraft has been in development for over 20 years
at a cost of over $20 billion USD.
quote: He also found that in an Osprey, he could recover from the condition relatively easily, provided he had 2,000 feet of altitude to play with
quote: Following established procedures, when the reset button on the Osprey's primary flight control system lit up, one of the pilots — either Lt. Col. Mi-chael Murphy or Lt. Col. Keith Sweaney — pushed it. Nothing happened. But as the button was pushed eight to 10 times in 20 seconds, a software failure caused the tilt-rotor aircraft to swerve out of control, stall and then crash near Camp Lejeune, N.C.
quote: ...Now, I know what you are thinking: The military ALWAYS blames the pilots.In this [crash], it was pilot error...The V-22 that crashed was in a two-ship formation when the lead ship started a rapid deceleration. The trailing ship (The one that crashed) followed the lead ship beyond the point where it was safe and entered a descent that was in excess of 3000 feet per minute... there is no reasonable person who would assume that a pilot induced descent in excess of 10 times the minimum required rate of descent to enter Vortex Ring State would be the fault of the aircraft . While I offer my condolences to the families of those who were killed, I must state that the excessive rate of descent was the problem here, not the aircraft design. Had the pilot broken formation and departed the landing zone to set up for a new approach, he probably would be alive today. Does that mean I am saying that the aircraft is perfect? No. It does have some problems that need to be worked out, but this specific situation is not a case where the aircraft design is at fault...