House Ponders E15 Rollback Amid Risk of Engine Damage
July 1, 2013 7:05 PM
comment(s) - last by
"Dirty" corn ethanol could soon be on the chopping block
Tom Buis, CEO of
-- a pro-corn ethanol lobby --
cheered a recent Supreme Court victory
over automakers and petroleum lobbyists who
looked to block the sale
, "Now that the final word has been issued, I hope that oil companies will begin to work with biofuel producers to help bring new blends into the marketplace that allow for consumer choice and savings."
Bob Dinneen, president of the Renewable Fuels Association (RFA) -- another top corn ethanol lobbying group -- echoes these sentiments. Even as automakers warn of dire engine damage, he
, "This is another example of oil companies unnecessarily scaring people, and it’s just flat-out wrong."
I. Corn Ethanol -- Good News or Bad?
But basic science suggests there may be more to it than that. In order to handle higher ethanol blends, engine and fuel system parts made of rubber, plastic, metal, and other materials in engines must be coated with special sealants to prevent
permeation of ethanol and degradation
. Older vehicles do not have that sealant -- so Mr. Dinneen appears to be basing his perspective on the fact that newer vehicles
, and thus will not be affected.
But aside from the engine life issue, there's other major concerns about corn ethanol. First, after years of government subsidies for the use of corn as a sweetener, the commercial food industry is deeply dependent on corn syrup -- and by proxy corn crops. Corn ethanol and corn syrup both compete for the same crop -- the most sugary breeds of corn. And even when corn ethanol producers ferment with lower sugar feed corn, they still raise prices of livestock feed,
bumping meat prices higher
. As a result, the corn ethanol industry has been shown to elevate food prices in multiple ways, according to experts.
The issues with corn ethanol run far deeper than engine damage. [Image Source: Digital Trends]
Further, while ethanol is more efficient (per cost) in single-mode engines, in dual-mode engines (using blends), it's been shown that the customer gets less fuel economy when using various blends than if they went all ethanol or all gas. In many cases this makes blended fuels more effective on a per-mile basis than gas. Ethanol proponents insist the market will adjust, but it's yet to be seen if that actually happens.
Lastly, there are questions over whether corn ethanol is greenwashing. When only emissions at the pipe are considered corn ethanol appears to cut emissions. But when the entire life cycle -- from plough to pipe -- is considered, it appears that
corn ethanol actually increases emissions
(unlike a number of alternative biofuels). Further, some have claimed the entire production process of ethanol has a net loss of energy, meaning that the industry uses more fuel to grow, harvest, and ship corn ethanol than it gets out.
But for all the criticism, the fact remains that ethanol increases are currently the law of the land.
The U.S. Environmental Protection Agency
(EPA) proposed this year raising blending targets 16.5 billion gallons, up 8.5 percent from a year ago. By 2022 production will double. If those targets remain in place, it will be virtually impossible for refiners to sell anything
E15. Refiners obtain a certain amount of credits for blending in ethanol; and if they don't blend enough they face stiff fines.
In fact, under the current rollout, it would be unsurprising to see E20 or E25 mixtures being forced into service to keep pace with the doubling of production quotas.
Many new vehicles -- including those from Chrysler Group LLC, Toyota Motor Corp. (
), Nissan Motor Comp., Ltd. (
), Bayerische Motoren Werke AG (
), and Volkswagen AG (
) still do not support E15; using E15 in them will void your warranty, according to the automakers, regardless of what the federal policy mandates. But this situation may worsen in years ahead, as even automakers like Ford Motor Comp. (
) who support E15 do not support E20 or E25 in most of their models (some "E85" capable vehicles are sold, but they remain a minority).
In other words, even if your vehicle can use E15 without damage, you may be in the same position Chrysler, Toyota, Nissan, BMW, and Volkswagen owners are in today, just down the road. When higher blends arrive, you may be just a fillup away from voiding your warranty.
II. Is it Time to Reform or Roll Back the Energy Act of 2007?
Amidst that backdrop, there is some growing momentum in Washington D.C. to roll back the
2007 Energy Act
, which was signed by President George W. Bush.
Rep. Fred Upton
(R-Mich.) chairman of the Energy and Commerce Committee
The Detroit News
as saying that a bill to reform that 2007 law is incoming, with the aim of passing it by the end of this year.
Much of the debate in the House currently centers on whether the best option is to kill the original law altogether, or whether it'd be better to modify it in some regard scaling back targets.
Rep. Joe Barton
(R-Texas) proposed killing it, but his colleague
Rep. Ed Whitfield
(R-Kentucky) is fighting to simply rework it, commenting, "We want is an RFS (renewable fuel standard) that can work for everyone involved, be it farmers, renewable fuel producers, refiners, and automakers. And most importantly, we want a policy that benefits the American driving public."
These stands represent largely who the representatives received their money from. Rep. Barton is funded/sponsored by the likes of Pickens Comp., and Exxon Mobil Corp. (
]. Rep. Whitfield is funded/sponsored by Koch Industries, who owns ethanol plants, and Caterpillar Inc. (
) who makes machinery used harvest corn [
The big question is what will happen if a repeal or reworking makes it to the Senate floor. The Democratic controlled Senate has shown very little interest in trimming back corn ethanol blending targets. The blame cannot be pinned solely on Democrats; both Senators from both parties have been more heavily funded by "big corn" than their House colleagues. That said, the Democrats are leading the push to protect corn ethanol at present, with the likes of Senators
(D/"Farmer-Labor Party"- Minnesota); and
Big corn has won over politicians with via its friend "bill". [Image Source: Agriculture.com]
In fact these Senators
proposed increasing ethanol quotas
via the trickily worded
Biofuels Expansion Act of 2011
. Thus it remains to be seen whether an effort to scale back targets can survive, amidst heavy lobbying from the corn industry (even as the other side lobbies hard as well).
Meanwhile the E15 mass rollout creeps closer. Currently only a handful of stations in the Midwest carry the blend, as most refiners have not yet started its mass production. But with the Supreme Court refusing to hear appeals on the standard, it seems just a matter of time before E15 is pouring out the pump across the nation -- even if that fuel damages your older vehicle, RV, boat, or motorcycle.
The Detroit News
This article is over a month old, voting and posting comments is disabled
Dr. Kenneth Noisewater
Dr. Kenneth Noisewater
7/2/2013 9:21:30 AM
Just goes to show what happens when you let centralized power get too concentrated. Local governments may cost less to corrupt but there's an awful lot of them and the voters are louder.
I actually don't mind flexfuel cars: their fuel systems are more robust and their fuel pumps and injectors are sized larger due to the energy difference between ethanol and gasoline, so they've got more 'overclock' potential since you can configure the computer to push gasoline at the rate of ethanol along with forced-air induction. I wouldn't even mind a mandate to make all gas/diesel cars flexfuel (to get economies of scale for those parts), but burning food for fuel is indeed quite stupid. Too bad there isn't a switchgrass lobby!
7/2/2013 9:26:44 AM
Why replace one retarded mandate with another retarded mandate? And how does that solve the problem of people with older cars that might not be built for higher ethanol contents?
7/3/2013 10:56:36 AM
Centralization is much more efficient if a country is geographically small and has excellent fast public transport.
The US is so large that Washington is much too insulted from the public, and the public is much to divided. Divide and conquer is a very effective tool, and the "two party" system works to enhance the geographical effect.
The US really would be better off today if it would divide itself into regions and decentralize quite a lot.
"Well, we didn't have anyone in line that got shot waiting for our system." -- Nintendo of America Vice President Perrin Kaplan
ITC Changes Rules to Block Foreign Patent "Trolling" Efforts
June 25, 2013, 11:30 AM
Supreme Court Asked to Rule on EPA's Ethanol Mandate
March 27, 2013, 9:05 AM
Obama's EPA Faces Decision Between Corn Ethanol Profits and Farm Jobs
October 12, 2012, 2:51 PM
EPA Clears the Way for E15 Fuel at Local Gas Stations
June 19, 2012, 9:34 AM
E15 Fuel Could Damage Cars According to Automakers, DOE Says "Whatever"
May 17, 2012, 9:57 AM
Quick Note: GM Teases Next Generation Chevrolet Volt
November 20, 2014, 3:26 PM
Audi is Latest to Step Into the Hydrogen Game, Delivers A7 Sportback h-tron quattro
November 19, 2014, 1:41 PM
Toyota’s Mirai Hydrogen Fuel Cell Vehicle Priced from $57,500 in the U.S.
November 18, 2014, 10:23 AM
Honda Still Pushing Hydrogen, Introduces FCV Fuel Cell Concept
November 17, 2014, 8:27 AM
Ford Enlists Wind Energy Corp. to Provide Wind, Solar Energy to Four U.S. Dealerships
November 10, 2014, 10:58 AM
AutoNation CEO Calls Slams Michigan’s “Anti-Tesla Bill”, Chides Elon Musk
November 7, 2014, 6:52 PM
Most Popular Articles
Austrian Pilots Call Surface 3 Pro Flight Bag a "Dream Come True"
November 14, 2014, 2:00 PM
U.S. Marshals Using Fake, Airplane-based Cell Towers to Scan Cell Phones of Americans
November 14, 2014, 9:05 AM
Wal-Mart: Miss Thanksgiving, Get Xbox One + Master Chief Collection for $299
November 17, 2014, 9:40 PM
Nokia Explores Two Paths Back to the Smartphone Market
November 14, 2014, 9:05 PM
Microsoft: All* Lumias Will Get Windows 10; Adds Real-Time Battery Live Tile
November 13, 2014, 6:32 PM
Latest Blog Posts
Costco Gives Employees Thanksgiving Off; Wal-Mart Leads "Black Thursday" Charge
Oct 29, 2014, 9:57 PM
"Bear Selfies" Fad Could Turn Deadly, Warn Nevada Wildlife Officials
Oct 28, 2014, 12:00 PM
The Surface Mini That Was Never Released Gets "Hands On" Treatment
Sep 26, 2014, 8:22 AM
ISIS Imposes Ban on Teaching Evolution in Iraq
Sep 17, 2014, 5:22 PM
Space Terrorism is a Looming Threat For the United States
Apr 23, 2014, 7:47 PM
More Blog Posts
Copyright 2014 DailyTech LLC. -
Terms, Conditions & Privacy Information