backtop


Print 28 comment(s) - last by johnsmith9875.. on Mar 6 at 11:44 PM

Second grounding of the F-35 fleet in one month comes to an end

The entire Lockheed Martin F-35 Lightning II fleet spent six days grounded after a crack was discovered in an engine component of one aircraft. Flights resumed on Friday afternoon, following the conclusion of an investigation into the problem according to officials for the F-35 program.

"Following engineering analysis of the turbine blade which developed a crack, F-35 flight operations have been cleared to resume," the Joint Program Office and Pratt & Whitney said in a joint statement.

"This decision concludes a cautionary flight suspension that began on Feb. 21 after a 0.6 inch crack was found on a 3rd stage turbine blade of a test aircraft at the Edwards Air Force Base F-35 Integrated Test Facility during a routine inspection.

"The engine in question is part of the F-35 test aircraft fleet, and had been operated at extreme parameters in its mission to expand the F-35 flight envelope. Prolonged exposure to high levels of heat and other operational stressors on this specific engine were determined to be the cause of the crack."
 
The statement also noted that no signs of similar engine stress or other cracks were found during inspections of the remaining F135 engine inventory for the F-35 fleet. The investigation also determined that no engine redesign was required because the crack was only found in a single aircraft turbine blade.

 
The Pentagon also announced a new deal clearing a path to eventually lead to the purchase of Lot 8 in the LRIP plan for the F-35. The deal is worth $333,786,000.

Source: Defense News



Comments     Threshold


This article is over a month old, voting and posting comments is disabled

Good to see the F-35 back in the air
By Beenthere on 3/4/2013 10:14:51 AM , Rating: 1
Durability stress testing serves a valuable purpose. One crack does not make for a problem considering the extensive, extreme testing that these engines go through. You can bet that there will continue to be extensive component inspections to insure no further issue exist even though the issue was only in one test engine.




RE: Good to see the F-35 back in the air
By Jeffk464 on 3/4/2013 4:51:47 PM , Rating: 2
A crack in a turbine or compressor can result in a catastrophic engine failure, its not that minor. If your remember a crack in a DC10 turbine wheel ended up bringing down the whole aircraft.


RE: Good to see the F-35 back in the air
By Nfarce on 3/4/2013 5:36:09 PM , Rating: 2
Only because the genius McDonnell-Douglas engineers decided to route all three hydraulic lines through the tail.


By Jeffk464 on 3/4/2013 9:14:14 PM , Rating: 2
wow, you know your stuff


By Amiga500 on 3/5/2013 2:05:44 PM , Rating: 2
More importantly, they didn't think it necessary to have shut-off valves that would close up the lines in the event of a leak.


By Skywalker123 on 3/6/2013 5:45:28 AM , Rating: 1
Nope, the f35 is a plane that should be junked.Its nothing but shit.http://www.counterpunch.org/2013/03/04/when-money-...


"You can bet that Sony built a long-term business plan about being successful in Japan and that business plan is crumbling." -- Peter Moore, 24 hours before his Microsoft resignation














botimage
Copyright 2014 DailyTech LLC. - RSS Feed | Advertise | About Us | Ethics | FAQ | Terms, Conditions & Privacy Information | Kristopher Kubicki