Iron Man: New Robotic Exoskeleton Helps Paraplegics Walk
October 31, 2012 3:30 PM
comment(s) - last by
New exoskeleton is the first to stimulate paralysis patients' muscles electrically, an effective therapy
stem cell therapies
a true "cure"
for paralysis in humans in decades to come, in the shorter term,
could provide an effective stopgap therapy. Several industry and research groups have been developing
, which offer load-bearing walking motions. In able-bodied humans, the skeletons can
help workers carry heavier loads
without joint stress. But in paraplegics the promise is even greater -- the exoskeletons could
allow them to "walk" again
I. Building a Cheaper, Better Medical Exoskeleton
are available to paraplegics, but they remain relatively expensive -- costing $140,000 USD or more. With that problem in mind, researchers at
Center for Intelligent Mechatronics
have designed a new "minimalist" robotic rehabilitative exoskeleton, and are
Parker Hannifin Corp. (
) to produce the device at a lower cost.
The device will compete with at least two other companies --
Argo Medical Technologies Ltd.
in Israel and
in Berkeley, Calif. -- for an estimated market of 236,000 to 327,000 patients in the U.S. suffering from severe spinal injuries.
The system is pretty standard, complete with hip and knee joints, which are robotic motors powered by rechargeable batteries. Unlike more ambitious, but more expensive designs, the system is not capable of solely maintaining balance. Paraplegic users will use the suit (which straps on around the waist and over the shoulders) to walk, but they'll have to use crutches to help maintain balance.
professor Michael Goldfarb
describes, "You can think of our exoskeleton as a Segway with legs. If the person wearing it leans forward, he moves forward. If he leans back and holds that position for a few seconds, he sits down. When he is sitting down, if he leans forward and holds that position for a few seconds, then he stands up."
Brian Shaffer, a paraplegic since 2010, tested the suit at a satellite facility in Nashville, Tenn. He recalls, "My kids have started calling me 'Ironman.' It's unbelievable to stand up again. It takes concentration to use it at first but, once you catch on, it's not that hard: The device does all the work. I don't expect that it will completely replace the wheelchair, but there are some situations, like walking your daughter down the aisle at her wedding or sitting in the bleachers watching your son play football, where it will be priceless."
II. Physical Therapy Success, Lays Groundwork for Home Use
An important note is that the device and its peers still are not geared for home use; they're targeted at a rehabilitative (think doctor's office) setting. But in terms of devices in that environment, the new exoskeleton appears very competitive.
The suit and similar models are not only liberating to the paralyzed; they can also cut down on serious health issues caused by sitting for prolonged periods in wheelchairs. It's light -- only 27 lb (versus the common weight of around 45 lb) -- and slim. The modular and minimalist design allows it to be folded up and transported on the back of a wheelchair.
The device also incorporates two other rehabilitative advances. First, it's capable of detecting users' muscle movements. That means in users with reduced capability, but not complete leg paralysis, the device can provide a less powerful amount of resistance. This "just enough" approach can help prevent joint damage in partially paralyzed individuals.
Vanderbilt's new exoskeleton is lighter than its rivals and bakes in new capabilities.
[Image Source: Vanderbilt/Parker Hannifin]
Second, the device claims to be the first exoskeleton to apply small electrical pulses to paralyzed muscles, causing them to contract and relax. This approach -- functional electrical stimulation (FES) -- has been shown to improve circulation, change bone density, and reduce muscle atrophy in victims of paralysis.
Clare Hartigan, a physical therapist at
, the medical center that helped test the device, did offer a warning for paraplegics that walking again wasn't as easy as they might hope -- it's a real workout. She states, "These new devices for walking are here and they are getting better and better. However, a person has to be physically fit to use them. They have to keep their weight below 220 pounds, develop adequate upper body strength to use a walker or forearm crutches and maintain flexibility in their shoulder, hip, knee and ankle joints ... which is not that easy when a person has relied on a wheelchair for months or even years."
Still, it's thrilling to watch iterative refinement of robotics exoskeletons for rehabilitation, a success that is almost surely a prelude to even more liberating exoskeletons for home use.
The suit design work was funded by a grant from the
National Institutes of Health
(NIH). Its other key contributors were research engineer
, graduate students Hugo Quintero, Spencer Murray and Kevin Ha, and
, a former student who now works for Parker Hannifin.
Vanderbilt [press release]
This article is over a month old, voting and posting comments is disabled
10/31/2012 7:51:01 PM
Why do you mention Ironman, whenever there is some news story about an exoskeleton? It seems silly, you should get some new material. :-)
RE: Why Ironman?
11/1/2012 3:36:38 PM
Page clicks. This is a business, after all.
"This week I got an iPhone. This weekend I got four chargers so I can keep it charged everywhere I go and a land line so I can actually make phone calls." -- Facebook CEO Mark Zuckerberg
NASA Builds an "Iron Man" Suit of Its Own
October 15, 2012, 2:03 PM
Kessler Releases Video Progress of "Ekso" Exoskeleton Testing; Clinical Trial Begins Jan. 2012
December 16, 2011, 9:43 AM
Human Astrocytes Used to Repair Spinal Cord Injuries in Rats
March 4, 2011, 1:25 PM
New Military Grade Exoskeleton Can Lift 200 lbs, March 12 Miles
October 26, 2010, 10:41 AM
Powered Exoskeleton Enables the Disabled to Walk Again
August 26, 2008, 12:52 PM
Star Wars Spinoff Film "Rogue One", Theme Park Attractions Announced
August 17, 2015, 12:20 PM
SpaceX Falcon 9's Seventh Supply Mission to ISS Ends w/ Fiery Stage 1 Explosion
June 28, 2015, 1:10 PM
Cool Science Video: Glowing Millipede Prowls the Nevada Desert
May 18, 2015, 12:00 PM
Newly Discovered Costa Rican Glass Frog is Kermit's Doppelgänger
April 22, 2015, 11:26 AM
Researchers Hope to Find "Exotic" Lifeforms Inside Crater of Dinosaur Killing Meteor
April 14, 2015, 8:47 PM
Mathematician's Sociological Formulation May Explain the "Hipster Paradox"
April 14, 2015, 1:13 PM
Most Popular Articles
Samsung Gear S2 Borrows Circular Icons From Apple Watch
August 21, 2015, 2:48 PM
Future of Lumia Uncertain as Microsoft Lays Off 2,300, Closes 1 of 3 Finnish Offices
August 24, 2015, 6:14 PM
Kentucky Man Faces up to 10 Years in Prison for Shooting Drone Trespasser
August 13, 2015, 2:58 PM
Microsoft's Windows 10 Leaves Lumia 530 Behind w/ 8 GB Storage Requirement
August 25, 2015, 4:02 PM
Aluminum 7003, Used in Roofing, May be Tapped by Apple for iPhone 6S/6S+
August 24, 2015, 4:45 PM
Latest Blog Posts
Sceptre Airs 27", 120 Hz. 1080p Monitor/HDTV w/ 5 ms Response Time for $220
Dec 3, 2014, 10:32 PM
Costco Gives Employees Thanksgiving Off; Wal-Mart Leads "Black Thursday" Charge
Oct 29, 2014, 9:57 PM
"Bear Selfies" Fad Could Turn Deadly, Warn Nevada Wildlife Officials
Oct 28, 2014, 12:00 PM
The Surface Mini That Was Never Released Gets "Hands On" Treatment
Sep 26, 2014, 8:22 AM
ISIS Imposes Ban on Teaching Evolution in Iraq
Sep 17, 2014, 5:22 PM
More Blog Posts
Copyright 2015 DailyTech LLC. -
Terms, Conditions & Privacy Information