Purdue Researchers Beef up Phone Nanofilters to Fight Dropped Calls
September 1, 2012 4:02 AM
comment(s) - last by
New device consists of a tiny, tunable silicon beam, could replace complex circuits, save power
As the wireless airspace
gets more crowded
much more pronounced. Indeed, while hard numbers are hard to come by, it is thought that much of
and slow data traffic is attributable to interference in cases where lack of coverage is not the issue.
All electronics devices incorporate some degree of filtering to deal with interference noise from other frequencies on a certain frequency band.
Purdue University researchers are working on making a superior type of filter, replacing the traditional digital filters made of transistors, inductors, and capacitors. The replacement uses a
tiny mechanical part
-- sometimes referred to as a nanoelectromechanical system (NEMS).
The NEMS device is created using silicon-on-insulator (SOI) -- a standard production process compatible with complementary metal–oxide–semiconductor technology (CMOS). T filter made by the Purdue team is a tiny silicon beam that is 2 microns (2 um) wide and 130 nm thick (about 1,000th the width of a human hair).
The NEMS device filters signals, and can also be used to measure mass. [Image Source: Purdue]
When exposed to voltage, the beam vibrates up-and-down or side-to-side, like a jump rope. The resulting device acts as a filter, accepting alternating current and outputting a pure filtered signal, based on the natural resonant frequency.
A big perk is that the simple process used to produce the NEMS has near 100 percent yields.
, an associate professor of mechanical engineering at Purdue, "There is not enough radio spectrum to account for everybody's handheld portable device. We are not inventing a new technology, we are making them using a process that's amenable to large-scale fabrication, which overcomes one of the biggest obstacles to the widespread commercial use of these devices. Because of manufacturing differences, no two nanoscale devices perform the same rolling off of the assembly line. You must be able to tune them after processing, which we can do with these devices."
, an associate professor of electrical and computer engineering at Purdue who co-authored the work, comments, "A vivid example [of the use of NEMS] is a tunable filter. It is very difficult to make a good tunable filter with transistors, inductors and other electronic components, but a simple nanomechanical resonator can do the job with much better performance and at a fraction of the power."
"Because the devices are tiny and the fabrication has almost a 100 percent yield, we can pack millions of these devices in a small chip if we need to. It's too early to know exactly how these will find application in computing, but since we can make these tiny mechanical devices as easily as transistors, we should be able to mix and match them with each other and also with transistors in order to achieve specific functions. Not only can you put them side-by-side with standard computer and electronic chips, but they tend to work with near 100 percent reliability."
The new NEMS device is produced using traditional SOI, at near 100 percent yields.
[Image Source: Purdue]
The beam could also be used as a sensor to detect minute masses. Professor Rhoads remarks, "The smaller your system, the smaller the mass you can measure. Most of the field-deployable sensors we've seen in the past have been based on microscale technologies, so this would be hundreds or thousands of times smaller, meaning we should eventually be able to measure things that much smaller."
A study on the work was
[abstract] in the peer-reviewed journal
IEEE Transactions on Nanotechnology
Professor Mohammadi is the senior author of the work, while
-- a Ph.D recipient in physics from Purdue -- is listed as the first author. The research was funded by grants from the
National Science Foundation
This article is over a month old, voting and posting comments is disabled
Simplicity at it's finest..
9/2/2012 9:51:25 PM
This is a pretty incredible, actually.. Simplicity at it's finest! A silicon beam that vibrates back and forth under voltage, activating the 'lag switches' on either side -- a mechanical design we've been using for centuries, elegantly integrated perfectly into a modern role on a miniscule scale. It's surprising that nobody came up with this idea sooner!
Can't help but think there will definitely be some incredible usage of this tech in next gen audio equipment -- it's about damn time they take a step ahead instead of just adding more transistors to the problem.
“Then they pop up and say ‘Hello, surprise! Give us your money or we will shut you down!' Screw them. Seriously, screw them. You can quote me on that.” -- Newegg Chief Legal Officer Lee Cheng referencing patent trolls
Obama Admin. Aims to "Share" Combat Aircraft Training Spectrum
March 28, 2012, 3:51 PM
LightSquared's GPS-Crippling 4G Bid is Sunk by the FCC
February 15, 2012, 1:18 PM
New Quarter-Sized Device Harvests Energy from Low-Frequency Vibrations
September 15, 2011, 7:08 PM
Apple Genius Considers 30 Percent NYC Call Drop Rates Normal
September 30, 2009, 4:54 PM
B-2 Bomber Radar Spectrum Accidentally Sold, Adds to Military Bandwidth Woes
March 23, 2009, 11:56 AM
Retiree Sues Apple For $7,500 for Wiping Honeymoon Photos From His iPhone
November 30, 2015, 10:23 AM
iPhone 7 May Pack 3-4 GB Memory, More Storage; 4-Inch Comeback is Rumored
November 20, 2015, 10:12 PM
OnePlus One, OnePlus 2 Will Receive Android Marshmallow in Q1 2016
November 16, 2015, 9:58 AM
Lenovo Whoa: Motorola Droid MAXX 2 and Turbo 2 Break Cover in Leaks
October 26, 2015, 3:12 PM
Leak: Apple Preps for First Real Android App Foray With New Apple Music App
October 24, 2015, 1:59 PM
Pepsi Smartphone? Empty Calories Coming Soon to the Midrange
October 12, 2015, 11:41 PM
Latest Blog Posts
Sceptre Airs 27", 120 Hz. 1080p Monitor/HDTV w/ 5 ms Response Time for $220
Dec 3, 2014, 10:32 PM
Costco Gives Employees Thanksgiving Off; Wal-Mart Leads "Black Thursday" Charge
Oct 29, 2014, 9:57 PM
"Bear Selfies" Fad Could Turn Deadly, Warn Nevada Wildlife Officials
Oct 28, 2014, 12:00 PM
The Surface Mini That Was Never Released Gets "Hands On" Treatment
Sep 26, 2014, 8:22 AM
ISIS Imposes Ban on Teaching Evolution in Iraq
Sep 17, 2014, 5:22 PM
More Blog Posts
Copyright 2016 DailyTech LLC. -
Terms, Conditions & Privacy Information