Chevrolet Volt Fire Leads to NHTSA Investigation of Lithium Batteries
November 12, 2011 1:36 AM
comment(s) - last by
Three weeks after a side-impact crash test on May 12, the Volt caught fire while parked in the NHTSA testing center
U.S. government safety regulators are conducting an investigation into the safety of lithium batteries in plug-in electric vehicles as a result of a
fire earlier this year.
Back in May, General Motor Co.'s Chevrolet Volt underwent a series of tests at the National Highway Traffic Safety Administration (NHTSA) facility in Wisconsin. Three weeks after a side-impact crash test on May 12, the Volt caught fire while parked in the testing center.
The fire was serious enough to burn other vehicles parked nearby, according to sources close to the talks who have requested to stay anonymous because the investigation is not yet public.
The fire has prompted an investigation of the safety of lithium batteries used in plug-in electric vehicles such as the Volt and Nissan's Leaf. Lithium batteries can catch fire if the internal cells or the battery case are pierced by steel or another ferrous metal, making the batteries a potential problem in car crashes. However, the batteries are usually heavily protected to prevent this from occurring.
Nevertheless, the NHTSA is looking into the safety because U.S. President Barack Obama is looking to put 1 million
electric vehicles on the roads by 2015
, and if there are any issues with these batteries, it wants to find it sooner rather than later.
Regulators have requested information about lithium batteries used from GM, Nissan, and Ford, and others who currently sell or plan to sell electric vehicles in the future.
GM defended the Volt after the fire, saying that
the EV's battery
, which is supplied by LG Chem Ltd., pose no greater threat than conventional cars. It added that GM has certain safety procedures for the Volt and the handling of its battery after an accident, and if these procedures would have been followed, the fire wouldn't have occurred.
"There are safety procedures for conventional cars," said Greg Martin, GM spokesman. "As we develop new technology, we need to ensure that safety protocols match the technology."
Even though the fire occurred three weeks after the side-impact crash, Munro said a small piercing of the battery can lead to a reaction days or weeks later.
The Wisconsin fire, however, is not the only EV fire that has occurred recently. NHTSA also sent investigators to Mooresville, North Carolina after a residential garage, which contained a charging Volt, caught fire. The investigation is ongoing.
"As manufacturers continue to develop vehicles of any kind -- electric, gasoline or diesel -- it is critical that they take the necessary steps to ensure the safety of drivers and first responders both during and after a crash," said NHTSA in an email statement on Friday. "Based on the available data, NHTSA does not believe the Volt or other electric vehicles are at a greater risk of fire than gasoline-powered vehicles. In fact, all vehicles -- both electric and gasoline-powered -- have some risk of fire in the event of a serious crash."
Katherine Zachary, spokeswoman for Nissan's U.S. unit, added that the Nissan Leaf hasn't had any reports of a fire. Over 8,000 Leafs are on U.S. roads today.
Nissan Leaf battery pack
has been designed with multiple safety systems in place to help ensure its safety in the real world," said Zachary. "All of our systems have been thoroughly tested to ensure real-world performance."
This article is over a month old, voting and posting comments is disabled
A little late
11/14/2011 1:50:24 PM
Reading the full article or the source would be helpful to understand.
After a major accident simulation that made a Volt undrivable and caused the battery coolant to drain, a Volt was parked and left totally alone. The Volt's gas tank was drained following standard procedure for this type of situation. But no attempt was made to drain
. Of course, the potentially damaged lithium battery with no coolant eventually posed a safety hazard. (One that would have been evident several days before the fire most likely)
This was done in direct opposite of GM's recommendation. In major accidents, the Volt's battery should be drained.
Most batteries have a little self-discharge similiar to a pilot light. Without a means to cool this pilot light (and a potentially faster burning pilot light), the Volt eventually caught fire. Is this different than a several compromised fuel system? Not really, but the "public" doesn't have a percention on what safety measures to take. Hopefully it becomes common knowledge that if a BEV/EREV etc is in a serious accident, the battery levels should be drained to low levels as soon as possible.
"I'm an Internet expert too. It's all right to wire the industrial zone only, but there are many problems if other regions of the North are wired." -- North Korean Supreme Commander Kim Jong-il
Chevrolet Volt Has Best-Ever Sales Month in October
November 2, 2011, 9:42 AM
Nissan Looks to Energy Storage for Old Leaf Battery Packs
July 11, 2011, 12:49 PM
UPDATED: White iPhone 4 to Launch Thursday
April 27, 2011, 9:24 AM
Obama Aims for $10k EVs, 20,000+ Charging Stations, and 1M EVs by 2015
July 14, 2010, 10:01 AM
Kia Partners with Greenlots to Provide DC Fast Chargers for ’15 Soul EV
September 2, 2014, 11:48 AM
Volkswagen e-Golf Priced from $35,445, Offers Up to 90-Mile Range
August 25, 2014, 12:35 PM
Owner of "Decepticon" Maserati Ordered to Appear in Court This Thursday
August 25, 2014, 7:55 AM
Watch Out Valets, Corvette is Offering "Baby Monitor for Your Car"
August 19, 2014, 5:05 PM
GM Concedes That the Cadillac ELR Doesn’t Really Compete with the Tesla Model S
August 15, 2014, 5:42 PM
Ford Partners with DTE Energy to Deploy MI’s Largest Solar Installation
August 14, 2014, 10:57 AM
Most Popular Articles
Numerous Leaks Detail 4.7" iPhone 6 Processor, RAM, Cellular and NFC Capabilities
August 29, 2014, 10:37 PM
Apple Builds Not-So-Secret Secret 3-Story Tower for iPhone 6/iWatch Unveil
August 28, 2014, 3:41 PM
Windows 9: "Upgrade Now" Button Coming for Enterprise Updates, ARM Preview in H1 2015
August 26, 2014, 8:00 PM
Buzz Grows Over Upcoming Lenovo Vibe X2's "Layered" Rim, Intel Chip
August 29, 2014, 4:59 PM
Comcast Forced Fees by Reducing Netflix to "VHS-Like Quality"
September 1, 2014, 7:18 PM
Latest Blog Posts
Space Terrorism is a Looming Threat For the United States
Apr 23, 2014, 7:47 PM
Facebook Aims to Provide Internet to "Every Person in the World" with Drones, Satellites
Apr 1, 2014, 10:20 AM
Retail Mobile Sites Experience Outages in Light of Simplexity's Bankruptcy
Mar 14, 2014, 8:48 AM
Tesla vs. BMW: Who Has the Safer EV?
Feb 1, 2014, 2:56 PM
Justice Leaks Details of Next HTC One Two Flagship Phone
Dec 5, 2013, 4:04 PM
More Blog Posts
Copyright 2014 DailyTech LLC. -
Terms, Conditions & Privacy Information