GM Begins Testing Production-Intent Fuel Cell System
March 18, 2010 1:00 PM
On the right is GM's fourth generation fuel cell stack, used in the 2007 Equinox FCV. On the left is the dramatically shrunk, lighter fuel cell, which still outputs the same power.
(Source: GM via Treehugger)
The old Equinox engine with its fuel cell system is seen on the left, with the petite new system on the right.
(Source: GM via Treehugger)
Company plans to sell vehicles with the system by 2015
Is the automotive market ready for fuel cell vehicles? Is it even ready for electric vehicles?
In both cases GM thinks the answer is "yes" and it is leading the charge to deploy these technologies. The
2011 Chevy Volt
, set to launch later this year, will be the first mass market electric vehicle to be sold in the U.S. (past EVs saw limited distribution). And GM
that it was beginning testing of production-intent fuel cells in preparation for a 2015 fuel cell (FC) vehicle launch.
In 2008, we
tested GM's Equinox FC vehicles
on the roads of Las Vegas. Since then the fleet has logged the most miles of any fuel cell fleet GM is aware of -- 1.3 million everyday miles in total.
GM has applied those lessons to make a dramatically improved
next generation fuel cell system
design. The design is 220 pounds lighter, is about half the size, and uses only about a third of the precious platinum that the 2008 cells used (80 grams used in the old stack, 30 g in the new stack).
Charles Freese, executive director of GM's Global Fuel Cell Activities states, "Our learning from Project Driveway has been tremendous and these vehicles have been very important to our program. The 30 months we committed to the demonstration are winding down, but we will keep upgrades of these vehicles running and will continue learning from them while we focus efforts on the production-intent program for 2015."
The launch of official testing of the new design will coincide with the wind down of GM's 2007 project, dubbed "Project Driveway". Elaborates Freese, "Some of the 119 fuel cell electric vehicles in Project Driveway will receive hardware and software upgrades and will become part of a technology demonstration program with the U.S. Department of Energy. Others will be driven by businesses and a few will be used to continue showing that, with proper fueling infrastructure, hydrogen fuel cells are a viable alternative to gasoline-powered vehicles. We will continue to use the Project Driveway fleet strategically to advance fuel cell technology, hydrogen infrastructure, and GM's vehicle electrification goals."
Stephanie White, a fuel cell advocate who was among the first Project Driveway participants and is an avid blogger on hydrogen in the automotive sector, was the first individual to receive a long-term loan of the next generation fuel cell vehicle.
She describes her past experiences, stating, "Driving the Chevy fuel cell around LA has been an amazing experience. People are always stopping me to ask questions about the vehicle and I tell them how powerful and eco-friendly it is."
Durability remains a concern for the cells. They currently are good for about 80,000 miles. GM hopes to bump that to 120,000 miles by 2015. GM also hopes to get the amount of platinum used in the stack under 10 g, while maintaining equivalent power. By 2015 the company plans on producing about 10,000 fuel cell vehicles a year.
GM still faces significant challenges even if it can produce a moderately affordable fuel cell design. Foremost is the lack of hydrogen infrastructure. With no infrastructure in place throughout much of the country, FC vehicles may only be able to operate in limited areas like
"Nowadays, security guys break the Mac every single day. Every single day, they come out with a total exploit, your machine can be taken over totally. I dare anybody to do that once a month on the Windows machine." -- Bill Gates
Hope for Hydrogen? Company to Build Series of Stations on East Coast
January 28, 2010, 11:42 AM
UPDATE: GM CEO: Chevy Volt Should Hit the Market at Close to $30k, Earn a Profit
January 19, 2010, 11:00 AM
GM to Launch Fifth Generation Fuel Cells, Commercial Hydrogen Vehicles in 2015
September 25, 2009, 5:48 PM
CES 2008 Ride and Drive with GM's Fuel Cell Equinox and DARPA Tahoe
January 11, 2008, 1:50 PM
Jaguar I-PACE – Jaguar’s New Electric Concept / New SUV
November 16, 2016, 5:00 AM
Car Insurance - The Hidden Discriminatory Practise
October 18, 2016, 5:00 AM
End of the Road for the Audi R8 e-tron
October 15, 2016, 5:00 AM
Paralyzed Race Car Driver Recieves Nevada License
October 12, 2016, 5:00 AM
Take a Glance at the Cars of the Paris 2016 Motor Show
October 4, 2016, 5:00 AM
Automaker Porsche may expand range of Panamera Coupe design.
September 18, 2016, 11:00 AM
Most Popular Articles
What Can You Do with Your New Echo Dot?
December 3, 2016, 5:00 AM
Google has developed Deep Learning Algorithm to detect Diabetic Eye Disease
December 4, 2016, 5:00 AM
Microsoft Surface – Which Surface is Right for You?
December 2, 2016, 5:00 AM
The iPlugmate is an Excellent iPhone Flash Drive at a Great Price. (Deal Expires in 3 Days)
November 23, 2016, 1:00 AM
Foscam R2 Home Security Camera System – High Quality High FHD Security Video Footage with No Monthly Fees
December 1, 2016, 2:00 AM
Latest Blog Posts
Latest Tech News
Dec 8, 2016, 5:11 AM
In The News
Dec 7, 2016, 5:00 AM
e Guide: Mobile Security for 2017
Dec 6, 2016, 5:00 AM
Apple Car is Not Dead
Dec 5, 2016, 1:00 AM
Dec 4, 2016, 5:00 AM
Dec 3, 2016, 5:00 AM
Dec 2, 2016, 5:00 AM
Surface Ergonomic Keyboard
Dec 1, 2016, 3:01 AM
Chapeconense plane crash: Football rallies around Brazilian Team
Nov 30, 2016, 1:00 AM
How to Extends Your iPhone’s Battery Life
Nov 29, 2016, 12:49 AM
Nov 28, 2016, 1:12 AM
News: Fidel Castro
Nov 27, 2016, 5:00 AM
Nov 26, 2016, 5:00 AM
Changes in Social status affect the way genes turn on and off within immune cells.
Nov 25, 2016, 5:12 AM
Austrian far–right hopeful Hofer may back EU vote.
Nov 24, 2016, 4:00 AM
Final Fantasy XV Leaked Before Nov 29 Launch Date
Nov 23, 2016, 1:00 AM
Nov 22, 2016, 2:26 AM
Nov 21, 2016, 1:00 AM
HTC Makes Big Moves in China
Nov 20, 2016, 2:00 AM
Do you know who is the number one company in the word?
Nov 19, 2016, 5:30 AM
More Blog Posts
Copyright 2016 DailyTech LLC. -
Terms, Conditions & Privacy Information