GM Begins Testing Production-Intent Fuel Cell System
March 18, 2010 1:00 PM
comment(s) - last by
On the right is GM's fourth generation fuel cell stack, used in the 2007 Equinox FCV. On the left is the dramatically shrunk, lighter fuel cell, which still outputs the same power.
(Source: GM via Treehugger)
The old Equinox engine with its fuel cell system is seen on the left, with the petite new system on the right.
(Source: GM via Treehugger)
Company plans to sell vehicles with the system by 2015
Is the automotive market ready for fuel cell vehicles? Is it even ready for electric vehicles?
In both cases GM thinks the answer is "yes" and it is leading the charge to deploy these technologies. The
2011 Chevy Volt
, set to launch later this year, will be the first mass market electric vehicle to be sold in the U.S. (past EVs saw limited distribution). And GM
that it was beginning testing of production-intent fuel cells in preparation for a 2015 fuel cell (FC) vehicle launch.
In 2008, we
tested GM's Equinox FC vehicles
on the roads of Las Vegas. Since then the fleet has logged the most miles of any fuel cell fleet GM is aware of -- 1.3 million everyday miles in total.
GM has applied those lessons to make a dramatically improved
next generation fuel cell system
design. The design is 220 pounds lighter, is about half the size, and uses only about a third of the precious platinum that the 2008 cells used (80 grams used in the old stack, 30 g in the new stack).
Charles Freese, executive director of GM's Global Fuel Cell Activities states, "Our learning from Project Driveway has been tremendous and these vehicles have been very important to our program. The 30 months we committed to the demonstration are winding down, but we will keep upgrades of these vehicles running and will continue learning from them while we focus efforts on the production-intent program for 2015."
The launch of official testing of the new design will coincide with the wind down of GM's 2007 project, dubbed "Project Driveway". Elaborates Freese, "Some of the 119 fuel cell electric vehicles in Project Driveway will receive hardware and software upgrades and will become part of a technology demonstration program with the U.S. Department of Energy. Others will be driven by businesses and a few will be used to continue showing that, with proper fueling infrastructure, hydrogen fuel cells are a viable alternative to gasoline-powered vehicles. We will continue to use the Project Driveway fleet strategically to advance fuel cell technology, hydrogen infrastructure, and GM's vehicle electrification goals."
Stephanie White, a fuel cell advocate who was among the first Project Driveway participants and is an avid blogger on hydrogen in the automotive sector, was the first individual to receive a long-term loan of the next generation fuel cell vehicle.
She describes her past experiences, stating, "Driving the Chevy fuel cell around LA has been an amazing experience. People are always stopping me to ask questions about the vehicle and I tell them how powerful and eco-friendly it is."
Durability remains a concern for the cells. They currently are good for about 80,000 miles. GM hopes to bump that to 120,000 miles by 2015. GM also hopes to get the amount of platinum used in the stack under 10 g, while maintaining equivalent power. By 2015 the company plans on producing about 10,000 fuel cell vehicles a year.
GM still faces significant challenges even if it can produce a moderately affordable fuel cell design. Foremost is the lack of hydrogen infrastructure. With no infrastructure in place throughout much of the country, FC vehicles may only be able to operate in limited areas like
This article is over a month old, voting and posting comments is disabled
RE: Hydrogen creation efficiency?
3/19/2010 11:19:59 AM
I was referring to the energy balance of the chemical reaction only. It doesn't matter how the chemical bonds are broken, the energy balance is the same. All of the externalities obviously affect the overall energy balance. The point is that there is no energy gained in the overall process.
RE: Hydrogen creation efficiency?
3/19/2010 12:34:24 PM
But I didn't see anyone claiming otherwise, that one could somehow get 'free energy' by splitting water, then burning the resultant H2. Did I just miss it?
"It's okay. The scenarios aren't that clear. But it's good looking. [Steve Jobs] does good design, and [the iPad] is absolutely a good example of that." -- Bill Gates on the Apple iPad
Hope for Hydrogen? Company to Build Series of Stations on East Coast
January 28, 2010, 11:42 AM
UPDATE: GM CEO: Chevy Volt Should Hit the Market at Close to $30k, Earn a Profit
January 19, 2010, 11:00 AM
GM to Launch Fifth Generation Fuel Cells, Commercial Hydrogen Vehicles in 2015
September 25, 2009, 5:48 PM
CES 2008 Ride and Drive with GM's Fuel Cell Equinox and DARPA Tahoe
January 11, 2008, 1:50 PM
Dual-Motor Tesla Model S P85D's "Insane Mode" Shocks Passengers
January 28, 2015, 11:18 PM
2016 Cadillac CTS-V Packs 640 hp Punch with 200 mph Reach
January 23, 2015, 3:25 PM
BMW Testing Tech to Allow Users to Auto-Park, Summon Cars Via Smartwatch
December 16, 2014, 9:30 AM
Lamborghini Offers Up $6,000 Leather-Bound Android Smartphone
December 12, 2014, 3:12 PM
Quick Note: GM Teases Next Generation Chevrolet Volt
November 20, 2014, 3:26 PM
Audi is Latest to Step Into the Hydrogen Game, Delivers A7 Sportback h-tron quattro
November 19, 2014, 1:41 PM
Most Popular Articles
Amid Tight Race w/ Evernote, Microsoft's OneNote Goes (Even More) Free, Adds Fresh Features
February 23, 2015, 11:15 AM
Google Steps up Snub of Adobe Flash, Auto-Converting Flash Ads to HTML5
February 25, 2015, 6:16 PM
Modern Glass (Windows 7 Aero Glass + Modern UI) Style is Coming to Windows 10
February 19, 2015, 1:05 PM
NVIDIA Bows to Outraged Overclockers, Will Restore Feature in Upcoming Driver
February 23, 2015, 12:30 PM
HTC's Sense UI is Garbage: A Tale of Disappearing Keyboards and Desperate Fixes
February 24, 2015, 11:00 AM
Latest Blog Posts
Sceptre Airs 27", 120 Hz. 1080p Monitor/HDTV w/ 5 ms Response Time for $220
Dec 3, 2014, 10:32 PM
Costco Gives Employees Thanksgiving Off; Wal-Mart Leads "Black Thursday" Charge
Oct 29, 2014, 9:57 PM
"Bear Selfies" Fad Could Turn Deadly, Warn Nevada Wildlife Officials
Oct 28, 2014, 12:00 PM
The Surface Mini That Was Never Released Gets "Hands On" Treatment
Sep 26, 2014, 8:22 AM
ISIS Imposes Ban on Teaching Evolution in Iraq
Sep 17, 2014, 5:22 PM
More Blog Posts
Copyright 2015 DailyTech LLC. -
Terms, Conditions & Privacy Information