GM Begins Testing Production-Intent Fuel Cell System
March 18, 2010 1:00 PM
comment(s) - last by
On the right is GM's fourth generation fuel cell stack, used in the 2007 Equinox FCV. On the left is the dramatically shrunk, lighter fuel cell, which still outputs the same power.
(Source: GM via Treehugger)
The old Equinox engine with its fuel cell system is seen on the left, with the petite new system on the right.
(Source: GM via Treehugger)
Company plans to sell vehicles with the system by 2015
Is the automotive market ready for fuel cell vehicles? Is it even ready for electric vehicles?
In both cases GM thinks the answer is "yes" and it is leading the charge to deploy these technologies. The
2011 Chevy Volt
, set to launch later this year, will be the first mass market electric vehicle to be sold in the U.S. (past EVs saw limited distribution). And GM
that it was beginning testing of production-intent fuel cells in preparation for a 2015 fuel cell (FC) vehicle launch.
In 2008, we
tested GM's Equinox FC vehicles
on the roads of Las Vegas. Since then the fleet has logged the most miles of any fuel cell fleet GM is aware of -- 1.3 million everyday miles in total.
GM has applied those lessons to make a dramatically improved
next generation fuel cell system
design. The design is 220 pounds lighter, is about half the size, and uses only about a third of the precious platinum that the 2008 cells used (80 grams used in the old stack, 30 g in the new stack).
Charles Freese, executive director of GM's Global Fuel Cell Activities states, "Our learning from Project Driveway has been tremendous and these vehicles have been very important to our program. The 30 months we committed to the demonstration are winding down, but we will keep upgrades of these vehicles running and will continue learning from them while we focus efforts on the production-intent program for 2015."
The launch of official testing of the new design will coincide with the wind down of GM's 2007 project, dubbed "Project Driveway". Elaborates Freese, "Some of the 119 fuel cell electric vehicles in Project Driveway will receive hardware and software upgrades and will become part of a technology demonstration program with the U.S. Department of Energy. Others will be driven by businesses and a few will be used to continue showing that, with proper fueling infrastructure, hydrogen fuel cells are a viable alternative to gasoline-powered vehicles. We will continue to use the Project Driveway fleet strategically to advance fuel cell technology, hydrogen infrastructure, and GM's vehicle electrification goals."
Stephanie White, a fuel cell advocate who was among the first Project Driveway participants and is an avid blogger on hydrogen in the automotive sector, was the first individual to receive a long-term loan of the next generation fuel cell vehicle.
She describes her past experiences, stating, "Driving the Chevy fuel cell around LA has been an amazing experience. People are always stopping me to ask questions about the vehicle and I tell them how powerful and eco-friendly it is."
Durability remains a concern for the cells. They currently are good for about 80,000 miles. GM hopes to bump that to 120,000 miles by 2015. GM also hopes to get the amount of platinum used in the stack under 10 g, while maintaining equivalent power. By 2015 the company plans on producing about 10,000 fuel cell vehicles a year.
GM still faces significant challenges even if it can produce a moderately affordable fuel cell design. Foremost is the lack of hydrogen infrastructure. With no infrastructure in place throughout much of the country, FC vehicles may only be able to operate in limited areas like
This article is over a month old, voting and posting comments is disabled
Nissan Leaf>Chevy Volt
3/18/2010 5:28:20 PM
The Nissan Leaf sounds a lot more promising than the Chevy Volt to me personally. Volkswagen has some nice cars coming out too with very high mileage as well.
Really what my dad said is the best short term idea, but very few vehicles actually run on is natural gas which is abundant in North America. The Swanson ice cream trucks run on it and a few other things, but not much in general.
"The Space Elevator will be built about 50 years after everyone stops laughing" -- Sir Arthur C. Clarke
Hope for Hydrogen? Company to Build Series of Stations on East Coast
January 28, 2010, 11:42 AM
UPDATE: GM CEO: Chevy Volt Should Hit the Market at Close to $30k, Earn a Profit
January 19, 2010, 11:00 AM
GM to Launch Fifth Generation Fuel Cells, Commercial Hydrogen Vehicles in 2015
September 25, 2009, 5:48 PM
CES 2008 Ride and Drive with GM's Fuel Cell Equinox and DARPA Tahoe
January 11, 2008, 1:50 PM
Reports: Porsche Working on Tesla Model S Competitor, All 991.2 911s to Get Turbo Engines
October 27, 2014, 8:28 AM
Michigan Governor Signs “Anti Tesla” Bill That Bans Direct Sales, GM Applauds Decision
October 22, 2014, 8:56 AM
Report: 2015 Ford Focus Electric MSRP Slashed by $6,000, Will Retail for $29,995
October 18, 2014, 6:23 PM
Chevrolet Sonic EV to Have 200-mile Range, Debut in 2017
October 10, 2014, 12:01 PM
Auto Start-Stop Systems Will be Installed on Nearly 60% of New Vehicles by 2020
October 8, 2014, 4:19 PM
Volvo XC90 to Receive Triple-turbocharged, 450hp 2.0-liter Four-cylinder Engine
October 7, 2014, 2:29 PM
Most Popular Articles
Amid Theater Boycott Netflix Defiantly Plans New Movies, Plus 3 TV Shows for 2015
October 24, 2014, 7:30 PM
AT&T Defeats Purpose of New Apple SIM, Locks iPad Air 2 SIMs to Its Network
October 24, 2014, 2:17 PM
CVS, Rite Aid Kill Unofficial Apple Pay Support, Burn Google Wallet Users in the Process
October 25, 2014, 5:26 PM
1 Million Credit Card Activated on Apple Pay Within 72 Hours, Walmart CEO Hopes Visa "Suffers"
October 28, 2014, 8:17 AM
Microsoft's Figures Show Desktop Users Flocking to Windows 10 Preview
October 27, 2014, 11:04 AM
Latest Blog Posts
Costco Gives Employees Thanksgiving Off; Wal-Mart Leads "Black Thursday" Charge
Oct 29, 2014, 9:57 PM
"Bear Selfies" Fad Could Turn Deadly, Warn Nevada Wildlife Officials
Oct 28, 2014, 12:00 PM
The Surface Mini That Was Never Released Gets "Hands On" Treatment
Sep 26, 2014, 8:22 AM
ISIS Imposes Ban on Teaching Evolution in Iraq
Sep 17, 2014, 5:22 PM
Space Terrorism is a Looming Threat For the United States
Apr 23, 2014, 7:47 PM
More Blog Posts
Copyright 2014 DailyTech LLC. -
Terms, Conditions & Privacy Information