GM Begins Testing Production-Intent Fuel Cell System
March 18, 2010 1:00 PM
On the right is GM's fourth generation fuel cell stack, used in the 2007 Equinox FCV. On the left is the dramatically shrunk, lighter fuel cell, which still outputs the same power.
(Source: GM via Treehugger)
The old Equinox engine with its fuel cell system is seen on the left, with the petite new system on the right.
(Source: GM via Treehugger)
Company plans to sell vehicles with the system by 2015
Is the automotive market ready for fuel cell vehicles? Is it even ready for electric vehicles?
In both cases GM thinks the answer is "yes" and it is leading the charge to deploy these technologies. The
2011 Chevy Volt
, set to launch later this year, will be the first mass market electric vehicle to be sold in the U.S. (past EVs saw limited distribution). And GM
that it was beginning testing of production-intent fuel cells in preparation for a 2015 fuel cell (FC) vehicle launch.
In 2008, we
tested GM's Equinox FC vehicles
on the roads of Las Vegas. Since then the fleet has logged the most miles of any fuel cell fleet GM is aware of -- 1.3 million everyday miles in total.
GM has applied those lessons to make a dramatically improved
next generation fuel cell system
design. The design is 220 pounds lighter, is about half the size, and uses only about a third of the precious platinum that the 2008 cells used (80 grams used in the old stack, 30 g in the new stack).
Charles Freese, executive director of GM's Global Fuel Cell Activities states, "Our learning from Project Driveway has been tremendous and these vehicles have been very important to our program. The 30 months we committed to the demonstration are winding down, but we will keep upgrades of these vehicles running and will continue learning from them while we focus efforts on the production-intent program for 2015."
The launch of official testing of the new design will coincide with the wind down of GM's 2007 project, dubbed "Project Driveway". Elaborates Freese, "Some of the 119 fuel cell electric vehicles in Project Driveway will receive hardware and software upgrades and will become part of a technology demonstration program with the U.S. Department of Energy. Others will be driven by businesses and a few will be used to continue showing that, with proper fueling infrastructure, hydrogen fuel cells are a viable alternative to gasoline-powered vehicles. We will continue to use the Project Driveway fleet strategically to advance fuel cell technology, hydrogen infrastructure, and GM's vehicle electrification goals."
Stephanie White, a fuel cell advocate who was among the first Project Driveway participants and is an avid blogger on hydrogen in the automotive sector, was the first individual to receive a long-term loan of the next generation fuel cell vehicle.
She describes her past experiences, stating, "Driving the Chevy fuel cell around LA has been an amazing experience. People are always stopping me to ask questions about the vehicle and I tell them how powerful and eco-friendly it is."
Durability remains a concern for the cells. They currently are good for about 80,000 miles. GM hopes to bump that to 120,000 miles by 2015. GM also hopes to get the amount of platinum used in the stack under 10 g, while maintaining equivalent power. By 2015 the company plans on producing about 10,000 fuel cell vehicles a year.
GM still faces significant challenges even if it can produce a moderately affordable fuel cell design. Foremost is the lack of hydrogen infrastructure. With no infrastructure in place throughout much of the country, FC vehicles may only be able to operate in limited areas like
"You can bet that Sony built a long-term business plan about being successful in Japan and that business plan is crumbling." -- Peter Moore, 24 hours before his Microsoft resignation
Hope for Hydrogen? Company to Build Series of Stations on East Coast
January 28, 2010, 11:42 AM
UPDATE: GM CEO: Chevy Volt Should Hit the Market at Close to $30k, Earn a Profit
January 19, 2010, 11:00 AM
GM to Launch Fifth Generation Fuel Cells, Commercial Hydrogen Vehicles in 2015
September 25, 2009, 5:48 PM
CES 2008 Ride and Drive with GM's Fuel Cell Equinox and DARPA Tahoe
January 11, 2008, 1:50 PM
Tesla will announce electric lorry in September
April 19, 2017, 6:20 AM
Dubai announces passenger drone plans.
February 14, 2017, 7:56 AM
Lucky LA Residence
January 28, 2017, 4:00 AM
Debuted at CES 2017 - Corning Gorilla Glass Concept Car
January 7, 2017, 3:02 AM
Happy, healthy and feastive New Year to you and everyone in the world that about to celebrate the Season Holidays
January 1, 2017, 12:01 AM
In 2017, Here are the New Autos of 2018
December 30, 2016, 5:00 AM
Most Popular Articles
Surface Pro 5 Rumors - New Release Date and Price
April 22, 2017, 6:45 AM
Apple Watch NikeLab Limited Edition unveiled.
April 22, 2017, 6:20 AM
SAPPHIRE PULSE Radeon RX 580 8GD5 – Great Value for the Money
April 20, 2017, 7:47 AM
Meet the Smartphone with four cameras - Alcatel Flashphone
April 5, 2017, 11:20 AM
Dell Inspiron 17 7000 – A Premium Laptop featuring 7th Gen Intel Core i7 in a 2-in-1 Frame.
April 19, 2017, 7:45 AM
Latest Blog Posts
Galaxy Note 8 – Available Second Half 2017
Apr 28, 2017, 7:30 AM
Google Android App – Huge improvement on Nighttime Photography
Apr 27, 2017, 7:40 AM
Google Co-Founder, Sergey Brin has an Airship
Apr 26, 2017, 6:43 AM
Samsung Galaxy S8 and S8 Plus – Lots of Glass that Breaks Easily
Apr 25, 2017, 7:20 AM
Samsung Galaxy S8 – Warning for Pet Owners
Apr 24, 2017, 5:59 AM
Sound Bars and the Costs?
Apr 23, 2017, 6:30 AM
Link your Brain to Your Computer – In Four Years…Maybe
Apr 22, 2017, 7:03 AM
Google Home can now identify users by their voice.
Apr 21, 2017, 7:15 AM
Amazon Lex – Now Available for Developers.
Apr 20, 2017, 6:58 AM
You can now use Instagram offline on your Android Smartphone
Apr 19, 2017, 8:00 AM
Now you can livestream to YouTube from your mobile device.
Apr 18, 2017, 8:05 AM
Google Home – Is It a Spy Device?
Apr 17, 2017, 7:30 AM
Apple added to self –driving test permit list
Apr 15, 2017, 6:21 AM
Project Scorpio – Coming on June 11
Apr 14, 2017, 6:20 AM
Looks Like Samsung Has Been Forgiven.
Apr 13, 2017, 6:50 AM
United Airlines - Blasted on China’s Social Network and the Stock Market
Apr 12, 2017, 6:50 AM
Amazon's Third-Party Sellers Hacked
Apr 11, 2017, 6:25 AM
Microsoft Surface Pro5 Details Revealed
Apr 9, 2017, 6:41 AM
Own An Android Phone? Then you could be hacked over Wi-FI
Apr 7, 2017, 6:47 AM
Apple confirms iOS 10.3 bug and its effect on iCloud Services
Apr 6, 2017, 6:30 AM
Apple Rolls Out New Version of Apple Music
Apr 5, 2017, 10:35 AM
Apple in the News
Apr 4, 2017, 9:03 AM
More Blog Posts
Copyright 2017 DailyTech LLC. -
Terms, Conditions & Privacy Information