GM Begins Testing Production-Intent Fuel Cell System
March 18, 2010 1:00 PM
On the right is GM's fourth generation fuel cell stack, used in the 2007 Equinox FCV. On the left is the dramatically shrunk, lighter fuel cell, which still outputs the same power.
(Source: GM via Treehugger)
The old Equinox engine with its fuel cell system is seen on the left, with the petite new system on the right.
(Source: GM via Treehugger)
Company plans to sell vehicles with the system by 2015
Is the automotive market ready for fuel cell vehicles? Is it even ready for electric vehicles?
In both cases GM thinks the answer is "yes" and it is leading the charge to deploy these technologies. The
2011 Chevy Volt
, set to launch later this year, will be the first mass market electric vehicle to be sold in the U.S. (past EVs saw limited distribution). And GM
that it was beginning testing of production-intent fuel cells in preparation for a 2015 fuel cell (FC) vehicle launch.
In 2008, we
tested GM's Equinox FC vehicles
on the roads of Las Vegas. Since then the fleet has logged the most miles of any fuel cell fleet GM is aware of -- 1.3 million everyday miles in total.
GM has applied those lessons to make a dramatically improved
next generation fuel cell system
design. The design is 220 pounds lighter, is about half the size, and uses only about a third of the precious platinum that the 2008 cells used (80 grams used in the old stack, 30 g in the new stack).
Charles Freese, executive director of GM's Global Fuel Cell Activities states, "Our learning from Project Driveway has been tremendous and these vehicles have been very important to our program. The 30 months we committed to the demonstration are winding down, but we will keep upgrades of these vehicles running and will continue learning from them while we focus efforts on the production-intent program for 2015."
The launch of official testing of the new design will coincide with the wind down of GM's 2007 project, dubbed "Project Driveway". Elaborates Freese, "Some of the 119 fuel cell electric vehicles in Project Driveway will receive hardware and software upgrades and will become part of a technology demonstration program with the U.S. Department of Energy. Others will be driven by businesses and a few will be used to continue showing that, with proper fueling infrastructure, hydrogen fuel cells are a viable alternative to gasoline-powered vehicles. We will continue to use the Project Driveway fleet strategically to advance fuel cell technology, hydrogen infrastructure, and GM's vehicle electrification goals."
Stephanie White, a fuel cell advocate who was among the first Project Driveway participants and is an avid blogger on hydrogen in the automotive sector, was the first individual to receive a long-term loan of the next generation fuel cell vehicle.
She describes her past experiences, stating, "Driving the Chevy fuel cell around LA has been an amazing experience. People are always stopping me to ask questions about the vehicle and I tell them how powerful and eco-friendly it is."
Durability remains a concern for the cells. They currently are good for about 80,000 miles. GM hopes to bump that to 120,000 miles by 2015. GM also hopes to get the amount of platinum used in the stack under 10 g, while maintaining equivalent power. By 2015 the company plans on producing about 10,000 fuel cell vehicles a year.
GM still faces significant challenges even if it can produce a moderately affordable fuel cell design. Foremost is the lack of hydrogen infrastructure. With no infrastructure in place throughout much of the country, FC vehicles may only be able to operate in limited areas like
"I want people to see my movies in the best formats possible. For [Paramount] to deny people who have Blu-ray sucks!" -- Movie Director Michael Bay
Hope for Hydrogen? Company to Build Series of Stations on East Coast
January 28, 2010, 11:42 AM
UPDATE: GM CEO: Chevy Volt Should Hit the Market at Close to $30k, Earn a Profit
January 19, 2010, 11:00 AM
GM to Launch Fifth Generation Fuel Cells, Commercial Hydrogen Vehicles in 2015
September 25, 2009, 5:48 PM
CES 2008 Ride and Drive with GM's Fuel Cell Equinox and DARPA Tahoe
January 11, 2008, 1:50 PM
Dubai announces passenger drone plans.
February 14, 2017, 7:56 AM
Lucky LA Residence
January 28, 2017, 4:00 AM
Debuted at CES 2017 - Corning Gorilla Glass Concept Car
January 7, 2017, 3:02 AM
Happy, healthy and feastive New Year to you and everyone in the world that about to celebrate the Season Holidays
January 1, 2017, 12:01 AM
In 2017, Here are the New Autos of 2018
December 30, 2016, 5:00 AM
What Happens When You Put a Blind Man in a Driverless Car?
December 14, 2016, 5:00 AM
Most Popular Articles
Intel Optane SSd DC P4800X – Super Fast 3D Storage
March 20, 2017, 7:35 AM
Comparison – Samsung Galaxy TabPro S Vs Microsoft Surface Pro 4
March 21, 2017, 7:40 AM
Gigabyte GA-Z170X-Gaming G1 – Intel Thunderbolt 3 Certified Motherboard
March 9, 2017, 6:25 AM
Samsung Galaxy S8, Rumored Launch Date!
March 18, 2017, 6:45 AM
Huawei P8 Lite 2017 – Android 7 Nougat Smartphone with Octa-Core Processor
March 8, 2017, 7:03 AM
Latest Blog Posts
Are you thinking of performance and speed? Intel claims:
Mar 25, 2017, 7:45 AM
Apple buys an automation app called Workflow. The deal was completed today and brings the app along with its developers.
Mar 23, 2017, 7:35 AM
Apple Announces new color for iPhones and iPads
Mar 22, 2017, 7:45 AM
Instagram: You Can Now Save Live Videos For Later
Mar 21, 2017, 7:49 AM
Samsung Galaxy S8 to Get New Color Scheme
Mar 20, 2017, 7:45 AM
What else to worry about?
Mar 17, 2017, 6:45 AM
Icon of the Day: Intel/ NVIDIA or Mobileye
Mar 16, 2017, 6:15 AM
JUST IN - Twitter Hijacked : High-Profile Account Accesses
Mar 15, 2017, 7:07 AM
Mar 14, 2017, 7:30 AM
News and Tips
Mar 13, 2017, 6:30 AM
iPhone 8 – May Not Get Curved Screen
Mar 11, 2017, 8:00 AM
California paves way to self-driving car tests without humans
Mar 11, 2017, 7:18 AM
Smart Machines V hackers
Mar 10, 2017, 7:00 AM
Uber Can Resume Autonomous Car Testing in California
Mar 9, 2017, 6:50 AM
Mar 8, 2017, 7:09 AM
Mar 7, 2017, 8:45 AM
World news 3-6
Mar 6, 2017, 5:40 AM
Mar 4, 2017, 7:40 AM
Mixed News of the Day
Mar 4, 2017, 6:32 AM
Jaguar Land Rover invests in ride-sharing
Mar 3, 2017, 7:00 AM
Mixed News of The World:
Mar 2, 2017, 7:02 AM
World New 3-1
Mar 1, 2017, 6:30 AM
More Blog Posts
Copyright 2017 DailyTech LLC. -
Terms, Conditions & Privacy Information