Samsung Shipping DDR NAND & 3-Bit MLC Flash, Expects Use in SSDs
December 1, 2009 8:21 AM
Samsung's 3-bit MLC NAND flash chips
Samsung's DDR NAND Flash
Your choice of higher speed or lower cost
Samsung Electronics is the largest NAND flash memory manufacturer in the world, accounting for 38.5 percent of the global market in Q3 of 2009. All of that money helps when conducting research and development into new technologies which are critical for maintaining that lead.
The company is making two NAND flash major announcements that will significantly affect consumers. The first is that it has started mass production of 30nm-class 32Gb Multi-Level Cell NAND flash memory with an asynchronous DDR interface. Samsung uses the term 30nm-class to refer to its manufacturing processes, which could range from 32nm to 34nm.
Single-Level Cell NAND flash has traditionally been faster than MLC NAND, but Samsung’s new DDR MLC NAND chip reads data at a very fast 133 Mbps. It is designed to replace the company's single data rate MLC NAND, which has an overall read performance of 40Mbps.
The process is yielding well enough that Samsung has already shipped its initial production run to major OEMs.
“With the new DDR MLC NAND, double data rate transmission can be achieved without increasing power consumption, giving designers a lot more latitude in introducing diverse CE devices.” said Soo-In Cho, Executive Vice President and General Manager of the Memory Division at Samsung Electronics.
Samsung's 30nm-class SDR NAND flash was rejected by many SSD manufacturers earlier this year, stating that it was
far too slow for use in SSDs
"Of course every transition to a new process has its problems," stated one source who requested anonymity. "We just weren't expecting it to be this slow".
put the blame on NAND flash controllers
that SSD makers were using, many of those companies reported that they had overcome similar but less severe problems with Toshiba's 34nm NAND flash memory.
Nevertheless, Samsung is hopeful that its new DDR NAND flash will help satisfy the need for speed from SSD makers. The new flash gives added urgency to new SSDs that can
support 6Gbps SATA
The company expects the new asynchronous DDR MLC NAND to be used in SSDs for PCs,
USB 3.0 flash drives
high-speed SDXC memory cards
, personal media players, and car navigation systems.
“Samsung’s accelerated push toward providing memory solutions at much higher speeds will enable faster introduction of high-performance mobile devices that deliver added convenience and greater value to consumers,” Mr. Cho added.
In a second announcement, Samsung states that it has begun the industry’s first volume production of 3-bit MLC NAND flash chips using 30nm-class process technology.
The first run of chips will be used in NAND flash modules accompanied by exclusive Samsung 3-bit NAND flash controllers to produce 8GB micro Secure Digital (microSD) cards.
“Introducing cost-efficient, 30nm-class 3-bit technology widens our NAND memory solution base to make NAND even more enticing for increasingly diverse market applications,” stated Mr. Cho.
Although 3-bit MLC has usually been slower and been capable of fewer read-write cycles than traditional 2-bit MLC, the 50 percent increase in capacity will allow Samsung to offer new NAND flash products at much lower prices. This could help lower prices of flash based devices like SSDs, which have increased in price as NAND flash prices doubled over the last six months.
“Our 3-bit NAND memory will support the development of more cost-competitive, high-density consumer electronics storage solutions,” Mr. Cho continued.
With new options for higher speed or lower cost, Samsung is adding choices for OEMs that will expand the overall flash market. Expect new SSDs and SDXC cards as these chips make their way into consumer products next year.
According to market research firm Gartner Dataquest, the global NAND flash memory market is forecast to be worth $13.8 billion this year, with sustained growth allowing it to reach $23.6 billion by 2012.
"I modded down, down, down, and the flames went higher." -- Sven Olsen
Lenovo, HP, Dell Integrating SDXC Readers in New 32nm Intel "Arrandale" Laptops
November 30, 2009, 11:46 AM
Super Talent Announces First USB 3.0 Flash Drive, Transfers at 320 MB/s
November 4, 2009, 10:15 AM
Motherboards Supporting USB 3.0 & SATA 6Gbps Now Available
November 4, 2009, 9:13 AM
Samsung Confirms 32nm Flash Problems, Working on New SSD Controller
October 2, 2009, 11:03 AM
Samsung's 32nm NAND Flash Problematic, Too Slow For SSDs
September 30, 2009, 11:36 AM
New Way to Read Data on Ulta Hard Drives
October 23, 2016, 9:38 AM
Asus: LGA 1151 Motherboards Are Ready for Kaby Lake
October 11, 2016, 5:00 AM
LG Gram Laptop
October 10, 2016, 5:00 AM
AMD, Zen Processor might power the upcoming Apple MacBook Pro
September 30, 2016, 5:00 AM
Laptop or Tablet - Which Do You Prefer?
September 20, 2016, 6:32 AM
Microsoft Surface Pro 3 - Battery Issue Fixed
August 30, 2016, 6:30 AM
Most Popular Articles
Apple iOS Contains Secret One-handed Keyboard Code
October 22, 2016, 5:00 AM
Thieves Love iPhones – More than $13,000 Stolen from Apple Store
October 21, 2016, 7:13 AM
Car Insurance - The Hidden Discriminatory Practise
October 18, 2016, 5:00 AM
The Unlocked Moto Z Play Launches for $449.99 Today.
October 22, 2016, 5:00 AM
The New HP Spectre: Revamped and Ready
October 23, 2016, 6:00 AM
Latest Blog Posts
Key EpiPen Competitor Out in 2017 At ' Very Low' Cost
Oct 27, 2016, 5:30 AM
Researchers use CRISPR to Accelerate Search for HIV Cure
Oct 26, 2016, 5:00 AM
Medical Council of India Makes Generic Medicines Mandatory
Oct 25, 2016, 5:00 AM
MacBoo Pro 2016: Release date Oct. 27
Oct 24, 2016, 7:16 AM
Mac Users, Try this if Your Mac is Infected?
Oct 23, 2016, 7:00 AM
Tips to Prevent Smartphones From Overheating:
Oct 22, 2016, 5:00 AM
Nasa Flies Drones at Nevada Airport
Oct 21, 2016, 8:21 AM
T-Mobile Data Problems
Oct 20, 2016, 10:17 AM
Annoying Apple Watch Problems and How to Fix Them
Oct 20, 2016, 5:00 AM
Your Mail May Soon Be Delivered By Robot
Oct 19, 2016, 9:34 AM
2018 Jeep Wrangler Prototype Sells At Junkyard
Oct 18, 2016, 5:00 AM
Samsung Shines with Gold Edition Tablet
Oct 17, 2016, 9:24 AM
Tesla Hints Mysterious Product Debut for October 17th
Oct 16, 2016, 10:14 AM
Samsung Galaxy Note 7 Phones on US flights
Oct 15, 2016, 5:00 AM
Comcast Fined $2.3 Million For Unconfirmed Services Charged To Customers
Oct 14, 2016, 5:00 AM
“American singer / songwriter “Bob Dylan is awarded 2016 Nobel Prize in Literature.
Oct 13, 2016, 10:33 AM
Battery Defect in Medical Device
Oct 12, 2016, 5:00 AM
More Blog Posts
Copyright 2016 DailyTech LLC. -
Terms, Conditions & Privacy Information