Samsung Shipping DDR NAND & 3-Bit MLC Flash, Expects Use in SSDs
December 1, 2009 8:21 AM
comment(s) - last by
Samsung's 3-bit MLC NAND flash chips
Samsung's DDR NAND Flash
Your choice of higher speed or lower cost
Samsung Electronics is the largest NAND flash memory manufacturer in the world, accounting for 38.5 percent of the global market in Q3 of 2009. All of that money helps when conducting research and development into new technologies which are critical for maintaining that lead.
The company is making two NAND flash major announcements that will significantly affect consumers. The first is that it has started mass production of 30nm-class 32Gb Multi-Level Cell NAND flash memory with an asynchronous DDR interface. Samsung uses the term 30nm-class to refer to its manufacturing processes, which could range from 32nm to 34nm.
Single-Level Cell NAND flash has traditionally been faster than MLC NAND, but Samsung’s new DDR MLC NAND chip reads data at a very fast 133 Mbps. It is designed to replace the company's single data rate MLC NAND, which has an overall read performance of 40Mbps.
The process is yielding well enough that Samsung has already shipped its initial production run to major OEMs.
“With the new DDR MLC NAND, double data rate transmission can be achieved without increasing power consumption, giving designers a lot more latitude in introducing diverse CE devices.” said Soo-In Cho, Executive Vice President and General Manager of the Memory Division at Samsung Electronics.
Samsung's 30nm-class SDR NAND flash was rejected by many SSD manufacturers earlier this year, stating that it was
far too slow for use in SSDs
"Of course every transition to a new process has its problems," stated one source who requested anonymity. "We just weren't expecting it to be this slow".
put the blame on NAND flash controllers
that SSD makers were using, many of those companies reported that they had overcome similar but less severe problems with Toshiba's 34nm NAND flash memory.
Nevertheless, Samsung is hopeful that its new DDR NAND flash will help satisfy the need for speed from SSD makers. The new flash gives added urgency to new SSDs that can
support 6Gbps SATA
The company expects the new asynchronous DDR MLC NAND to be used in SSDs for PCs,
USB 3.0 flash drives
high-speed SDXC memory cards
, personal media players, and car navigation systems.
“Samsung’s accelerated push toward providing memory solutions at much higher speeds will enable faster introduction of high-performance mobile devices that deliver added convenience and greater value to consumers,” Mr. Cho added.
In a second announcement, Samsung states that it has begun the industry’s first volume production of 3-bit MLC NAND flash chips using 30nm-class process technology.
The first run of chips will be used in NAND flash modules accompanied by exclusive Samsung 3-bit NAND flash controllers to produce 8GB micro Secure Digital (microSD) cards.
“Introducing cost-efficient, 30nm-class 3-bit technology widens our NAND memory solution base to make NAND even more enticing for increasingly diverse market applications,” stated Mr. Cho.
Although 3-bit MLC has usually been slower and been capable of fewer read-write cycles than traditional 2-bit MLC, the 50 percent increase in capacity will allow Samsung to offer new NAND flash products at much lower prices. This could help lower prices of flash based devices like SSDs, which have increased in price as NAND flash prices doubled over the last six months.
“Our 3-bit NAND memory will support the development of more cost-competitive, high-density consumer electronics storage solutions,” Mr. Cho continued.
With new options for higher speed or lower cost, Samsung is adding choices for OEMs that will expand the overall flash market. Expect new SSDs and SDXC cards as these chips make their way into consumer products next year.
According to market research firm Gartner Dataquest, the global NAND flash memory market is forecast to be worth $13.8 billion this year, with sustained growth allowing it to reach $23.6 billion by 2012.
This article is over a month old, voting and posting comments is disabled
12/1/2009 8:53:24 AM
"The new flash gives added urgency to new SSDs that will finally see the use of interfaces that can support 6Gbps SATA."
also, to remain ontopic. Sure would be great if a product came out that aimed for just slightly better performance than mechanical, but keeping price down as well.
12/1/2009 10:34:10 AM
Yeah, because THAT would'nt be complete waste of money or anything.
12/1/2009 10:54:35 AM
"We are going to continue to work with them to make sure they understand the reality of the Internet. A lot of these people don't have Ph.Ds, and they don't have a degree in computer science." -- RIM co-CEO Michael Lazaridis
Lenovo, HP, Dell Integrating SDXC Readers in New 32nm Intel "Arrandale" Laptops
November 30, 2009, 11:46 AM
Super Talent Announces First USB 3.0 Flash Drive, Transfers at 320 MB/s
November 4, 2009, 10:15 AM
Motherboards Supporting USB 3.0 & SATA 6Gbps Now Available
November 4, 2009, 9:13 AM
Samsung Confirms 32nm Flash Problems, Working on New SSD Controller
October 2, 2009, 11:03 AM
Samsung's 32nm NAND Flash Problematic, Too Slow For SSDs
September 30, 2009, 11:36 AM
Laptop or Tablet - Which Do You Prefer?
September 20, 2016, 6:32 AM
Microsoft Surface Pro 3 - Battery Issue Fixed
August 30, 2016, 6:30 AM
First Apple Computer Auctions for $815,000
August 27, 2016, 7:51 AM
Lenovo vs. Asus vs. HP - Best Laptop Under $500.00
August 19, 2016, 4:00 AM
Best Router for Your Home Network (Under $200.00)
August 6, 2016, 9:51 PM
5 Top Rated Printers for Home or Small Office
July 29, 2016, 10:44 PM
Most Popular Articles
5 Cases for iPhone 7 and 7 iPhone Plus
September 18, 2016, 10:08 AM
No More Turtlenecks - Try Snakables
September 19, 2016, 7:44 AM
ADHD Diagnosis and Treatment in Children: Problem or Paranoia?
September 19, 2016, 5:30 AM
Walmart may get "Robot Shopping Carts?"
September 17, 2016, 6:01 AM
Automaker Porsche may expand range of Panamera Coupe design.
September 18, 2016, 11:00 AM
Latest Blog Posts
Who is in Risk of Getting Oral Cancer?
Sep 23, 2016, 6:02 AM
France Bans Plastic Eating Utensils in Restaurants
Sep 18, 2016, 10:49 AM
Progress Against Acute Myeloid Leukemia
Sep 17, 2016, 5:30 AM
Apple Watch Series 2 - Number 1 in the Customer Satisfaction.
Sep 7, 2016, 6:19 PM
First Self-Driving Car debut on the streets of Singapore
Aug 28, 2016, 4:10 PM
More Blog Posts
Copyright 2016 DailyTech LLC. -
Terms, Conditions & Privacy Information