Print 76 comment(s) - last by XtremeM3.. on Oct 20 at 3:04 AM

Eight 2011 Chevy Volts took the 1200-mile roadtrip.  (Source: Jeffrey Sauger for General Motors)
The Volt is withstanding the rigors of road testing admirably

The first preproduction models of the 2011 Chevy Volt hybrid electric plug-in vehicle were built earlier this year.  Since then, the vehicle has been put through a number of rigorous tests.  Starting yesterday, a fleet of eight Volts launched on the most ambitious test of the vehicle to date: a 1,200 mile road trip.

Chevrolet Volt chief engineer Andrew Farah is among those making the round trip from the Milford Proving Ground through Ohio, Pennsylvania, Maryland, West Virginia, before returning home.  The drive will take a few days and will require approximately 4 tanks of gas.

The drive is dubbed the "65-Percent Drive" according to Autoblog, which in GM-speak means the test drive made when 65 percent of the vehicle's hardware and software is done.  Reportedly, GM is actually about 90 percent done, but is just sticking to its traditional naming.  GM will complete 70, 80, 90 and 100 percent drives in coming months.

One thing GM is still tweaking is how much power from the gas-engine generator to put directly to the electric drive motor, versus using the generator power to charge the batteries.  GM is finding that frequently putting the power directly to the motor improves performance.  However, the generator will still charge the batteries in some cases, as well.

The engine will be run between 1,200 and 4,000 rpm, using factors like speed and power load requirements to decide on the necessary speed.  GM wants to keep the engine between 30 to 100 percent load, as higher loads reduce pumping losses.  GM was tight lipped about fuel economy under the old method (sustained charge) or the new method (variable speed, some power going directly to the electric motor). 

The company did say that the prototypes are getting good mileage -- over 300 miles on a tank of gas -- when operating in generator mode.  This is in addition to the vehicle's 40 mile all-electric range.  Another interesting test will be when GM runs the car's gas engine on E85 ethanol fuel.  The vehicles are FlexFuel designs, so they can enjoy both gas and ethanol.

As to the battery mode, the batteries are performing well and aren't getting too cold or too hot, both conditions which can degrade performance.  The cars aren't yet reaching the 40 mile target on a charge, but GM expects to pass that milestone on the next test, with tweaking.  On the trip, GM is testing vehicles both running on a depleted battery charge, and a full charge.

GM is also looking to fine tune and minimize noise, vibration, and harshness (NVH).  Currently, the gas engine typically won't turn on until the car is moving, at which point the noise will be drowned out by the wind and road noises.  GM, nonetheless, is pleased with the performance, and plans to further reduce NVH by tweaking vehicle parameters that effect the road and wind noise.

Other GM engineers were off testing Volts at Pikes Peak in Colorado.  One key concern is whether the Volt will reach a "tipping point", where the gas engine can't sustain battery charging, and the battery becomes depleted below the typical minimum of 30 percent charge.  Even a strenuous 14-mile trip to the 14,000-foot summit was unable to overwhelm the 100 hp generator, though, so it appears that the "tipping point" will never be reached in real world situations  -- if GM's claims hold true.

A critical test to come will be how the vehicle performs in cold weather.  In cold weather, the Volt starts with the generator running, to help heat up vehicle and jump-start performance.  Battery performance typically suffers incrementally worse degradation, the colder it gets (this is a major argument for ultracapacitors which perform favorably, but are more expensive).

Comments     Threshold

This article is over a month old, voting and posting comments is disabled

RE: looks
By Reclaimer77 on 10/16/2009 2:36:36 PM , Rating: 2
lol yeah I agree. Anyone buying GM right now has to be the dumbest person on Earth. Let's see, they take your tax money to bail them out. They become part of the Federal Government at this point. And then, you give them MORE money to buy a vehicle.

You know what you just did ? You taxed yourself. Good job, moron lol.

RE: looks
By mcnabney on 10/16/2009 2:45:14 PM , Rating: 2
The government owns non-voting shares of GM in exchange for their investment. It doesn't make it part of the Federal government any more than my investment in Microsoft makes me involved in their business. The Feds will sell their stake as soon as they can find a buyer to give them most of their money back (unlikely for the Feds to make money on their GM investment, I know). But your reasoning of avoiding GM because of the investment actually will decrease the government's return and loss more of YOUR tax dollars.
So if you use the investment model of invest in what you buy and buy what you invest in, it is in every US citizen's best interest to buy products that they have invested in.

RE: looks
By Reclaimer77 on 10/16/2009 2:52:30 PM , Rating: 2
So if you use the investment model of invest in what you buy and buy what you invest in, it is in every US citizen's best interest to buy products that they have invested in.

Investment implies we had a choice. We never did. I didn't choose to invest in GM, so I choose to do the most I can to not support them.

p.s. screw you.

RE: looks
By MadMan007 on 10/16/09, Rating: 0
RE: looks
By mcnabney on 10/16/2009 3:57:37 PM , Rating: 2
The US government 'invests' in tons of things, many of them through private companies. You are using one of those 'investments' right now. The internet cost the US taxpayer billions in giveaways. So you better get offline, hypocrite.

Also, the footprint of GM failing outright - across suppliers, vendors, and employees is huge. My company, who is a vendor, would have lost tens of millions.

RE: looks
By Reclaimer77 on 10/16/2009 4:37:07 PM , Rating: 1
Really the Internet was a private business, who the government gave billions to, fired it's CEO, and then told them how to run their business ???

Brilliant analogy mcnabney !!

I suppose I should get off the roads because taxes pay for that too ? Or did you not actually get my point...

Also, the footprint of GM failing outright - across suppliers, vendors, and employees is huge. My company, who is a vendor, would have lost tens of millions.

We HAVE lost tens of millions, more. And GM HAS laid off thousands of people and closed tons of dealerships, the same thing that WOULD HAVE HAPPENED IF THEY WERE ALLOWED TO GO INTO BANKRUPTCY. Do you get it ?

RE: looks
By mcnabney on 10/16/2009 5:19:40 PM , Rating: 5
Actually, unassisted they would have gone into liquidation. All assets sold, creditors paid in order of seniority. Vendors would have gotten nothing. Warranties would be cancelled. No bank was in a position to assist in a reorganization. Only the Federal government could do it. And yes, firing the leadership was the best thing that happened. There was plenty of griping about management getting the money during the Circuit City selloff period.

And also, who do you think paid for most of the network, routers, and many servers in the early years of the Internet and Web. The Feds through grants and direct investment. What, you think private and public universities just print the money? All they paid for was local servers. The Bells got to keep the wire, but the cost of putting it in was Federal.

RE: looks
By MadMan007 on 10/16/2009 5:26:58 PM , Rating: 3
Your logical and factual debating points are not wanted here! Away with thee!

RE: looks
By mcnabney on 10/17/2009 1:53:58 PM , Rating: 2
Sorry. I'll go back to work.


RE: looks
By Reclaimer77 on 10/16/2009 5:39:08 PM , Rating: 2
Wrong. ALL BANKRUPTCIES for a company that large are federally assisted. All of those things would have happened anyway. The goal wasn't to "save GM", the goal was to keep the unions ( and their campaign contributions ) and take over the company.

Do all you people watch MSNBC or something ? Have you actually noticed who's running GM now and what their board of directors is made up of ? There are more union guys and politicians running the company than actual car people now.

And weather or not GM's CEO " had to go " isn't even the issue here. The President fired him, which is beyond unconstitutional. This kind of stuff is the EXACT reason businesses and government don't mix and why we were against the bailouts.

What happened to GM is just wrong. Period. It's wrong for the taxpayer, and in the longrun it will be bad for them as well as the country.

RE: looks
By mcnabney on 10/17/2009 1:51:41 PM , Rating: 2
They are all managed by Federal bankruptcy courts, but financing is typically arranged from large banking/investment institutions. For example, Enron and MCI/Worldcom didn't cost the Feds anything. I even believe that the court costs were paid from the remaining assets. The Chrysler bankruptcy involved Fiat and some cash there, but for the most part the court just assisted in negotiating new terms for some debts and discharging others. Before that can be done the entire financial structure of the business has to be studied to make sure there aren't tangential assests that can be liquidated. For example, in the GM bankruptcy the Saab and Hummer brands were sold. Saturn would have been, but Penske flaked-out. In GM's case the Feds played the role of a large bank by buying a major percentage of the business ownership after the previous shares were cancelled. This actually worked out as it should. The equity investors were punished first by getting nothing. Second, the bond holders only received a fraction of their matured value (that is where a lot of US funds went to). Third, management was fired w/o parachutes. Fourth, employee stakes were converted to shares which made them dependant on future prospects to have any value. If the whole thing fails, the Feds won't be able to sell their equity stake in the future to get there money back. Long story short - if you want the US taxpayers to get their investment back, buy GM products.

RE: looks
By Reclaimer77 on 10/17/2009 2:42:55 PM , Rating: 2
Ok I see we have fundamental differences of opinion that aren't going to be resolved by picking at the edges of arguments.

I'm apposed to the concept that any business is "too large to fail" and that it's up to the taxpayers, in a big recession I might add, to pick up the tab and bail them out. Especially without even a vote ! Taxation without representation ring a bell to you ? We weren't even given a CHANCE to have an honest and democratic debate on this issue. This is NOT the way things should be done. I, and a great many other Americans, are honestly sick and tired of crap being rammed down our throats before anyone even knows what's going on or has a say in it. The TARP, the Auto Bailouts, the "Stimulus", Tax and Trade, and now Universal Healthcare.

Period. No iff's, and's or buts. And I find your assertion that it's our patriotic duty to buy into the farce that is Government Motors, frankly, offensive.

"Game reviewers fought each other to write the most glowing coverage possible for the powerhouse Sony, MS systems. Reviewers flipped coins to see who would review the Nintendo Wii. The losers got stuck with the job." -- Andy Marken

Most Popular Articles5 Cases for iPhone 7 and 7 iPhone Plus
September 18, 2016, 10:08 AM
Automaker Porsche may expand range of Panamera Coupe design.
September 18, 2016, 11:00 AM
Walmart may get "Robot Shopping Carts?"
September 17, 2016, 6:01 AM
No More Turtlenecks - Try Snakables
September 19, 2016, 7:44 AM
ADHD Diagnosis and Treatment in Children: Problem or Paranoia?
September 19, 2016, 5:30 AM

Copyright 2016 DailyTech LLC. - RSS Feed | Advertise | About Us | Ethics | FAQ | Terms, Conditions & Privacy Information | Kristopher Kubicki