Print 65 comment(s) - last by icanhascpu.. on May 30 at 3:28 PM

JMicron seeks redemption with a new chip that could drive mainstream SSD adoption

DailyTech has learned that JMicron will be unveiling a new NAND flash controller for use in Solid State Drives (SSDs) in the near future. The JMF612 chip uses an ARM9 core in a 289-ball TFBGA package, and will support the use of up to 256MB of DDR or DDR2 DRAM as an external cache.

The new chip was designed to remedy stuttering problems during random write operations, which has plagued SSDs using the JMF602 flash controller. JMicron rushed out a JMF602B chip to address shortcomings, but was only partially successful. Several firms decided to combine two JMF602B chips and an internal RAID chip from JMicron to boost performance. Although it raised costs significantly, it was still cheaper than controllers from Samsung and Indilinx, which were not yet available at the time. It was for this reason that SSDs like OCZ's Apex and G.Skill's Titan series were born.

The JMF612 chip is designed especially for a new generation of NAND flash chips built using smaller process geometries that will be entering the market soon. The new flash chips will be smaller, faster, and cheaper to manufacture. IM Flash Technologies, a joint venture between Intel and Micron, is already building 34nm NAND, while 32nm NAND from Samsung and Toshiba will soon be entering production. The use of a cheap single-chip controller and new higher density flash chips could cut prices in half by the vital Christmas shopping season.

SSDs using the chip will also be able to support Native Command Queuing (NCQ), which was designed to increase performance of SATA hard disks by allowing the drive to internally optimize the order in which read and write commands are executed. NCQ is used in SSDs when there is latency due to high CPU usage. It also supports 128-bit Advanced Encryption Standard (AES) protocols for full disk encryption. This provides data security mandated for classified and/or privileged information in government and corporations.

While most drives using the new chip will be designed for its SATA II interface in mind, it does have a USB 2.0 interface for data transfers and firmware updates. The JMF612 has an ARM9 embedded processor with 32KB of ROM and 128KB of RAM at its core. Data integrity is provided by BCH ECC in hardware, with the ability to correct up to 24 random bit errors per 1024 bytes. Dynamic and static wear leveling technologies, along with updated bad block management software help to ensure long life of the drive.

The first terabyte SSDs on the market could end up using this controller chip. It uses eight memory channels to access its storage quickly and without lag.

JMicron will be showing engineering samples of its latest controller at Computex 2009 at the beginning of June. Mass production of the new chip is expected to start in July. The company is also working on a flash controller that will work at SATA 6Gbps speeds, but it is not expected to be ready for mass production until the middle of 2010.

Comments     Threshold

This article is over a month old, voting and posting comments is disabled

RE: To the doubters out there
By DeepBlue1975 on 5/26/2009 2:41:29 PM , Rating: -1
Conservationists have always been there saying things like "no, that's not possible, not now, not ever".
And history has been proving them wrong almost every single time when it comes to technological innovations.

And why is that? because those don't usually care to review what happened before, and how seemingly impossible to overcome barriers have been worked around by some kind of break through...

Remember these

More than 3gbs/platter in a 3.5" drive??? impossible!!!!
Enter giant-magneto resistive heads, courtesy of IBM.

More than 70gb/platter??? no daemonic way!!!
Enter PMR...

Transistor densities' impossible growth limitations?
Enter copper interconnects, SOI, better lithography processes...

Those who say "oh, it's impossible" DO NOT realize that behind the companies that actually makes tech innovations for a living, are lots of high-range PhDs crammed into their R&D departments, and getting payed just to make the formerly impossible, become possible. And when talking about computer tech, they almost do it every damn single time.

RE: To the doubters out there
By Jansen on 5/26/2009 3:24:24 PM , Rating: 2
I'm going to assume you meant "conservatives" instead of "conservationists".

RE: To the doubters out there
By therealnickdanger on 5/26/2009 3:35:02 PM , Rating: 4
Why would you assume that? It still wouldn't make sense. :P

RE: To the doubters out there
By Merlyn2220 on 5/26/2009 9:35:36 PM , Rating: 2
I think the right word is "pessimists." Why would conservatives or conservationists be against the advance of technology? :) Post is okay...the opening is confusing to those of us with lesser intellect.

RE: To the doubters out there
By DeepBlue1975 on 5/27/2009 3:30:33 PM , Rating: 2

That post of mine is a complete and utter disaster.

Even now I don't get exactly what I said, though of course I know what I tried to say.

I just meant this:

There are those who always seem to think "inside the box" and extrapolate the already known rules and limitations in a way so absolute that, for them, those limitations are final and imply a rather permanent dead end regarding a certain branch of technological development.

But they forget that research teams actually try to shift the playing ground from a known set of rules and limits, to another that allows those limits to be set much further away and, hence, allowing for the development efforts to continue.

Those "new sets of rules and limits" I mention, are nothing more than the breakthroughs we're used to read about: a new material that allows better conductivity at the same temperature, an effect that wasn't known before and that by doing some working around could save the day, a complete shift of paradigm, and so on.

I hope this is less confusing. Yesterday my mind was rather messy and, adding that to the fact that English is not my birth language, yielded that horrible post of mine. Heck, even I'd rate it down further if I could :D

RE: To the doubters out there
By wingless on 5/26/2009 4:27:43 PM , Rating: 1
After the tower of Babel was built, God said this about humanity, "Look, they are one people, and they have all one language; and this is only the beginning of what they will do; nothing that they propse to do will now be impossible for them..." Genesis 11:6

Even God said we can do anything we put our minds too (we just rarely have the wisdom to use it). Never say never.

I want to see an HTX interface SSD that runs at full Hyper Transport 3.1 bus speeds. Until then, I'm sure we will saturate a PCIe 8x or 16x bus easily come mid 2010.

RE: To the doubters out there
By JS on 5/26/2009 5:42:19 PM , Rating: 3
That was a pretty uncool thing to do, putting humanity down like that. I guess we' will soon know if he will allow for JMicron to keep pulling their stunts.

Oh wait, I forgot, they're probably mostly Buddhist.

RE: To the doubters out there
By Visual on 5/27/2009 4:22:42 AM , Rating: 2
We'll get back on him, don't worry.
Once we make our space elevator, we'll silently declare it a "tower" and name the anchoring platform "Babel" and take God by surprise ;)

"Death Is Very Likely The Single Best Invention Of Life" -- Steve Jobs

Copyright 2016 DailyTech LLC. - RSS Feed | Advertise | About Us | Ethics | FAQ | Terms, Conditions & Privacy Information | Kristopher Kubicki