Print 103 comment(s) - last by randomly.. on Aug 29 at 12:13 PM

The upcoming Chevrolet Cruze will use a turbocharged 1.4-liter four-cylinder gasoline engine.

The Pontiac Solstice GXP uses a turbocharged, direct injection 2.0-liter four-cylinder engine.

Chevrolet Malibu Hybrid
GM goes high-tech to improve fuel efficiency

General Motors has seen the writing on the walls when it comes to efficient vehicles. Although gas prices have dropped more than 15 cents in the past few weeks, Americans are still gravitating towards smaller vehicles that are easier on the wallet when the times comes to fill up the tank.

GM has spent the past few years working on a number of technologies to bring lightweight, advanced, and fuel efficient powertrains to its vehicles and a number of them are already available or will soon be hitting the general populous.

GM's reinvigorated powertrain efforts revolve around traditional gasoline engines, diesels, hybrids, and Homogeneous Charge Compression Ignition (HCCI) engines according to Automotive News. GM is also looking to replace nearly all of its existing four and five-speed automatic transmissions with more efficient six-speed units.

For its gasoline engines -- much like Ford's efforts with its EcoBoost lineup -- GM is looking towards direct injection (DI) and turbocharging to extract V6 performance from four-cylinder engines and V8 performance from six-cylinder engines. GM's current turbocharged DI 2.0-liter four-cylinder engine can be found in the Pontiac Solstice GXP, Saturn Sky Red Line, Chevrolet HHR SS, and the Chevrolet Cobalt SS. In its current form, the engine delivers an impressive 260 HP and 260 lb-ft of torque.

In the near future, GM will apply turbocharging to its existing DI 3.6-liter six-cylinder engine to boost output from roughly 300 HP to around 400 HP. On the lower end of the spectrum, a new 1.4-liter turbocharged four-cylinder engine will finds its way into the Chevrolet Cruz -- the replacement for the Chevrolet Cobalt -- in place of the existing 2.2-liter normally aspirated (NA) four-cylinder engine.

On the diesel front, GM points to its upcoming 4.5-liter V8 diesel engine which will be used in its light-duty pickups and full-size SUVs. According to GM, the engine itself is 75 pounds lighter than traditional diesel engines and will allow its hefty trucks to achieve 26 MPG on the highway.

When it comes to hybrids, GM is already making ground with its mild hybrid system in the Chevrolet Malibu Hybrid and Saturn Aura Green Line. Eventually, the company's more efficient two-mode hybrid system -- currently used in full-size pickups and SUVs -- will find its way into the Saturn Vue Green Line and GM's other mid-size cars and SUVs.

Finally, GM is also banking on HCCI technology to extract diesel-like fuel economy from a gasoline engine. DailyTech first brought you news of this technology when Mercedes unveiled its F700 research vehicle. According to GM, adding HCCI to a gasoline engine boost fuel economy by 15 percent and significantly reduced harmful tailpipe emissions.

GM hopes to stay a step ahead of its competitors with its upcoming powertrain advances; however, its competitors likely aren't sitting still when it comes to their own efforts in striving for greater performance and engine efficiency.

Comments     Threshold

This article is over a month old, voting and posting comments is disabled

RE: Good to see
By theapparition on 8/26/2008 2:03:33 PM , Rating: 3
Have to disagree. My wife's stock 08 C6 is getting an average of 24mpg. That's a combined average, made up of mostly city driving.

I'd suggest your foot is just a little bit too heavy. I also fall into that catagory, so don't be offended. Both my C5 and C6 get an average of closer to 20mpg.

My two vettes don't count since they are "slightly" modified.

Climate, driving conditions and tuning all make a huge difference. With a good tune, you should really be able to gain performance and increase gas milage, signifigantly. The cars come pig rich from the factory.

RE: Good to see
By FITCamaro on 8/26/2008 2:12:19 PM , Rating: 1
Exactly. I mean hell my dad's Trans Am gets 27 mpg at 75-80 mph and its a hell of a lot less aerodynamic than a Vette.

What I'm really wondering with the Vettes is why they haven't introduced the 3-valve heads on them yet. They demoed them like 3 years ago.

RE: Good to see
By Spuke on 8/26/2008 3:23:22 PM , Rating: 2
Well, if we're going to use real world driving. My Solstice gets 28 mpg on commutes with a lead foot. 30 mpg on 80 mph freeway jaunts (with some point and squirt driving) and 33 mpg on that same freeway drive if I manage to keep my foot off the floor.

Other drivers report much higher freeway figures but they're also driving at 60-65 mph. A place I don't go.

RE: Good to see
By FITCamaro on 8/26/2008 5:00:03 PM , Rating: 1
Ok and? I think that turbo-Ecotec is a great engine. I know it gets good fuel economy and makes great power.

RE: Good to see
By fxnick on 8/29/2008 2:41:13 AM , Rating: 2
3 valves on a pushrod motor? ive never heard of such a thing. they must have been using a different engine.

“Then they pop up and say ‘Hello, surprise! Give us your money or we will shut you down!' Screw them. Seriously, screw them. You can quote me on that.” -- Newegg Chief Legal Officer Lee Cheng referencing patent trolls

Copyright 2016 DailyTech LLC. - RSS Feed | Advertise | About Us | Ethics | FAQ | Terms, Conditions & Privacy Information | Kristopher Kubicki