backtop


Print 103 comment(s) - last by randomly.. on Aug 29 at 12:13 PM


The upcoming Chevrolet Cruze will use a turbocharged 1.4-liter four-cylinder gasoline engine.

The Pontiac Solstice GXP uses a turbocharged, direct injection 2.0-liter four-cylinder engine.

Chevrolet Malibu Hybrid
GM goes high-tech to improve fuel efficiency

General Motors has seen the writing on the walls when it comes to efficient vehicles. Although gas prices have dropped more than 15 cents in the past few weeks, Americans are still gravitating towards smaller vehicles that are easier on the wallet when the times comes to fill up the tank.

GM has spent the past few years working on a number of technologies to bring lightweight, advanced, and fuel efficient powertrains to its vehicles and a number of them are already available or will soon be hitting the general populous.

GM's reinvigorated powertrain efforts revolve around traditional gasoline engines, diesels, hybrids, and Homogeneous Charge Compression Ignition (HCCI) engines according to Automotive News. GM is also looking to replace nearly all of its existing four and five-speed automatic transmissions with more efficient six-speed units.

For its gasoline engines -- much like Ford's efforts with its EcoBoost lineup -- GM is looking towards direct injection (DI) and turbocharging to extract V6 performance from four-cylinder engines and V8 performance from six-cylinder engines. GM's current turbocharged DI 2.0-liter four-cylinder engine can be found in the Pontiac Solstice GXP, Saturn Sky Red Line, Chevrolet HHR SS, and the Chevrolet Cobalt SS. In its current form, the engine delivers an impressive 260 HP and 260 lb-ft of torque.

In the near future, GM will apply turbocharging to its existing DI 3.6-liter six-cylinder engine to boost output from roughly 300 HP to around 400 HP. On the lower end of the spectrum, a new 1.4-liter turbocharged four-cylinder engine will finds its way into the Chevrolet Cruz -- the replacement for the Chevrolet Cobalt -- in place of the existing 2.2-liter normally aspirated (NA) four-cylinder engine.

On the diesel front, GM points to its upcoming 4.5-liter V8 diesel engine which will be used in its light-duty pickups and full-size SUVs. According to GM, the engine itself is 75 pounds lighter than traditional diesel engines and will allow its hefty trucks to achieve 26 MPG on the highway.

When it comes to hybrids, GM is already making ground with its mild hybrid system in the Chevrolet Malibu Hybrid and Saturn Aura Green Line. Eventually, the company's more efficient two-mode hybrid system -- currently used in full-size pickups and SUVs -- will find its way into the Saturn Vue Green Line and GM's other mid-size cars and SUVs.

Finally, GM is also banking on HCCI technology to extract diesel-like fuel economy from a gasoline engine. DailyTech first brought you news of this technology when Mercedes unveiled its F700 research vehicle. According to GM, adding HCCI to a gasoline engine boost fuel economy by 15 percent and significantly reduced harmful tailpipe emissions.

GM hopes to stay a step ahead of its competitors with its upcoming powertrain advances; however, its competitors likely aren't sitting still when it comes to their own efforts in striving for greater performance and engine efficiency.



Comments     Threshold


This article is over a month old, voting and posting comments is disabled

RE: Good to see
By Chaser on 8/26/2008 12:47:44 PM , Rating: 2
As a C6 Corvette owner the Corvette is a car of extremes. Driving on the highway with very little traffic to help maintain 65 miles per hour in top 6th gear over a period of time will gain you 26MPH -with a tail wind. :) Under all other circumstances the Vette gets 16. ALL other circumstances. The Solstice on the other hand will get 19 when driving it hard, but maintain a noticably higher average in "everyday" city driving and get 27MPH when on the highway in almost all circumstances.


RE: Good to see
By theapparition on 8/26/2008 2:03:33 PM , Rating: 3
Have to disagree. My wife's stock 08 C6 is getting an average of 24mpg. That's a combined average, made up of mostly city driving.

I'd suggest your foot is just a little bit too heavy. I also fall into that catagory, so don't be offended. Both my C5 and C6 get an average of closer to 20mpg.

My two vettes don't count since they are "slightly" modified.
:P

Climate, driving conditions and tuning all make a huge difference. With a good tune, you should really be able to gain performance and increase gas milage, signifigantly. The cars come pig rich from the factory.


RE: Good to see
By FITCamaro on 8/26/2008 2:12:19 PM , Rating: 1
Exactly. I mean hell my dad's Trans Am gets 27 mpg at 75-80 mph and its a hell of a lot less aerodynamic than a Vette.

What I'm really wondering with the Vettes is why they haven't introduced the 3-valve heads on them yet. They demoed them like 3 years ago.


RE: Good to see
By Spuke on 8/26/2008 3:23:22 PM , Rating: 2
Well, if we're going to use real world driving. My Solstice gets 28 mpg on commutes with a lead foot. 30 mpg on 80 mph freeway jaunts (with some point and squirt driving) and 33 mpg on that same freeway drive if I manage to keep my foot off the floor.

Other drivers report much higher freeway figures but they're also driving at 60-65 mph. A place I don't go.


RE: Good to see
By FITCamaro on 8/26/2008 5:00:03 PM , Rating: 1
Ok and? I think that turbo-Ecotec is a great engine. I know it gets good fuel economy and makes great power.


RE: Good to see
By fxnick on 8/29/2008 2:41:13 AM , Rating: 2
3 valves on a pushrod motor? ive never heard of such a thing. they must have been using a different engine.


RE: Good to see
By FITCamaro on 8/26/2008 2:05:53 PM , Rating: 2
Don't know what options or whatnot you've got. But all the C6 6-speed owners I've talked to are getting 28-29+ MPG on the highway at 75 mph. At 65 it should be even better.


RE: Good to see
By lightfoot on 8/26/2008 2:45:34 PM , Rating: 2
As a Saturn Sky Redline (the solstice's twin) owner I have to say that you're exactly right. For me it's almost impossible to get less than 25 MPG in the Sky regardless of driving style, but on the highway I can regularly get 30-32. The 27 MPG quote is for the non-turbo charged 2.4L V4, not the 2.0L turbo-V4. The EPA highway of the Solstice/Sky is 29MPG. In any case it is wrong to say that 16 vs. 19 city mileage is a minimal difference - It's HUGE the Corvette uses 18.75% more fuel in city driving, and 11.5% more fuel on the highway. Not to mention the fact that the Corvette is going to cost you double the amount up front. Is the ‘Vette a more efficient engine? Yes it is, but large engines typically are.

The whole argument is silly - these are both performance cars - mileage is not a major concern. What really matters to owners of these cars is this: the Corvette will do in 3.7 seconds what the Sky/Solstice takes 5.5 seconds to do. That's the 0-60 time, and that is why people buy these cars. And they both get incredible mileage while having the ability to do so.

If you really want mileage, then buy a Smart car. It will cost you 1/6th the 'Vette, and 1/3 the Solstice and it will beat the socks off both of them in MPG - you just have to settle for a 12+ second 0-60 time.


RE: Good to see
By FITCamaro on 8/26/2008 5:02:22 PM , Rating: 2
Buying a SMART car is the dumbest thing you can do. Other far larger cars can nearly match its MPG and don't involve driving a gift box for a car (not even a shoe box).


RE: Good to see
By Spuke on 8/26/2008 6:15:26 PM , Rating: 2
quote:
don't involve driving a gift box for a car (not even a shoe box)
LOL! Kinda looks like my Logitech mouse.


RE: Good to see
By lightfoot on 8/26/2008 10:01:11 PM , Rating: 2
I don't disagree, but econo-boxes aren't performance cars and they shouldn't be compared. The Smart car is only slightly smaller than the Sky/Solstice and thus was a good parallel. If you don't need to haul cargo, and only need a single passenger they will both do the job. However, if all you care about is fuel economy, the Smart is the better choice.


"Well, we didn't have anyone in line that got shot waiting for our system." -- Nintendo of America Vice President Perrin Kaplan














botimage
Copyright 2014 DailyTech LLC. - RSS Feed | Advertise | About Us | Ethics | FAQ | Terms, Conditions & Privacy Information | Kristopher Kubicki