backtop


Print 103 comment(s) - last by randomly.. on Aug 29 at 12:13 PM


The upcoming Chevrolet Cruze will use a turbocharged 1.4-liter four-cylinder gasoline engine.

The Pontiac Solstice GXP uses a turbocharged, direct injection 2.0-liter four-cylinder engine.

Chevrolet Malibu Hybrid
GM goes high-tech to improve fuel efficiency

General Motors has seen the writing on the walls when it comes to efficient vehicles. Although gas prices have dropped more than 15 cents in the past few weeks, Americans are still gravitating towards smaller vehicles that are easier on the wallet when the times comes to fill up the tank.

GM has spent the past few years working on a number of technologies to bring lightweight, advanced, and fuel efficient powertrains to its vehicles and a number of them are already available or will soon be hitting the general populous.

GM's reinvigorated powertrain efforts revolve around traditional gasoline engines, diesels, hybrids, and Homogeneous Charge Compression Ignition (HCCI) engines according to Automotive News. GM is also looking to replace nearly all of its existing four and five-speed automatic transmissions with more efficient six-speed units.

For its gasoline engines -- much like Ford's efforts with its EcoBoost lineup -- GM is looking towards direct injection (DI) and turbocharging to extract V6 performance from four-cylinder engines and V8 performance from six-cylinder engines. GM's current turbocharged DI 2.0-liter four-cylinder engine can be found in the Pontiac Solstice GXP, Saturn Sky Red Line, Chevrolet HHR SS, and the Chevrolet Cobalt SS. In its current form, the engine delivers an impressive 260 HP and 260 lb-ft of torque.

In the near future, GM will apply turbocharging to its existing DI 3.6-liter six-cylinder engine to boost output from roughly 300 HP to around 400 HP. On the lower end of the spectrum, a new 1.4-liter turbocharged four-cylinder engine will finds its way into the Chevrolet Cruz -- the replacement for the Chevrolet Cobalt -- in place of the existing 2.2-liter normally aspirated (NA) four-cylinder engine.

On the diesel front, GM points to its upcoming 4.5-liter V8 diesel engine which will be used in its light-duty pickups and full-size SUVs. According to GM, the engine itself is 75 pounds lighter than traditional diesel engines and will allow its hefty trucks to achieve 26 MPG on the highway.

When it comes to hybrids, GM is already making ground with its mild hybrid system in the Chevrolet Malibu Hybrid and Saturn Aura Green Line. Eventually, the company's more efficient two-mode hybrid system -- currently used in full-size pickups and SUVs -- will find its way into the Saturn Vue Green Line and GM's other mid-size cars and SUVs.

Finally, GM is also banking on HCCI technology to extract diesel-like fuel economy from a gasoline engine. DailyTech first brought you news of this technology when Mercedes unveiled its F700 research vehicle. According to GM, adding HCCI to a gasoline engine boost fuel economy by 15 percent and significantly reduced harmful tailpipe emissions.

GM hopes to stay a step ahead of its competitors with its upcoming powertrain advances; however, its competitors likely aren't sitting still when it comes to their own efforts in striving for greater performance and engine efficiency.



Comments     Threshold


This article is over a month old, voting and posting comments is disabled

RE: Good to see
By Chris Peredun on 8/26/2008 11:54:04 AM , Rating: 2
I'm having a heck of a time finding the torque numbers, but the European Opel Astra 1.4L Turbo made 140hp out of that tiny little engine, and I saw references to a "weaker 125hp engine" making ~200NM, or about 145lb-ft.

I agree about the looks (and bring back the front-shot in red!) but I wish GM would stop with this divided grille schtick. Remove that "top grille" above the emblem, and put the emblem in the middle of the black area, and it would look much sharper in my opinion.


RE: Good to see
By Brandon Hill (blog) on 8/26/2008 12:09:25 PM , Rating: 4
Ask and ye shall receive.


RE: Good to see
By Totally on 8/26/2008 9:56:01 PM , Rating: 1
those modifications to the front end would make the car kind of ugly.

I just wish Ford would show as much enthusiasm to innovate as Chevy does.


RE: Good to see
By Samus on 8/27/2008 5:59:48 PM , Rating: 2
quote:
I'm having a heck of a time finding the torque numbers, but the European Opel Astra 1.4L Turbo made 140hp out of that tiny little engine, and I saw references to a "weaker 125hp engine" making ~200NM, or about 145lb-ft.


I drove a 98 Mazda Protege with a 96HP, 1.5l engine for five years back in the day and it wasn't only the most reliable car I even owned (the only two things that failed was the exhaust manifold cracking and the A/C clutch bearing failing, both around 70k, and both less than a few hundred each to replace. It was a 5-speed, and although it was very low performance, it was very light and handled very well allowing me to keep my speed high through onramps and twists.

Some american's might shun 96hp cars, especially if equiped with an automatic transmission, but 30/38mpg fuel economy fully equiped for $15,000 and world-class Japanese construction in the luxury Millenia construction plant make it my favorite car of all time. I wish the same could be said about current Mazda's. The company have lost its roots of making small, nimble, fuel efficient cars. Thanks Ford.


"Mac OS X is like living in a farmhouse in the country with no locks, and Windows is living in a house with bars on the windows in the bad part of town." -- Charlie Miller














botimage
Copyright 2014 DailyTech LLC. - RSS Feed | Advertise | About Us | Ethics | FAQ | Terms, Conditions & Privacy Information | Kristopher Kubicki