Using Nanowire Silicon Thermoelectrics to Capture Waste Heat
January 21, 2008 3:17 AM
comment(s) - last by
Professor Peidong Yang led the University of California, Berkley team who discovered silicon nanowire's thermoelectric properties.
(Source: University of California, Berkley)
A scanning electron microscope image of a thin silicon nanowire stretching between two heating pads, one as a heat source, the other as a sensor.
(Source: A. Hochbaum)
Silicon heat capture could allow cheap refrigeration and energy saving
Among the many valuable properties of silicon is its ability to
capture solar energy
to create electricity via its photoelectric character. Now scientists are discovering that silicon, when properly prepared, can form a very good thermoelectric as well. This opens the door to a plethora of uses, including refrigeration, solar heat power generation, and power generation from other heat sources, such as computer waste heat or car heat.
has two basic modes of operation. When a thermoelectric is placed over a heat gradient, it generates an electric current. The other mode is the reverse; when a thermoelectric is exposed to an electric current, it creates a heat difference, cooling one side of it, and warming the other side. Thus thermoelectrics are applicable to power generation, refrigeration and heating.
Traditional thermoelectrics, which have been around since the 1960s, rely on either bismuth telluride or lead telluride. These materials are relatively expensive due to scarcity and lack of a large manufacturing infrastructure. They are also bulky and require more material, which further increaese their cost. While thermoelectric coolers have achieved modest commercial usage in seat coolers and picnic coolers, they have yet to realize their full potential.
may change that. Professor Peidong Yang and his colleagues at the University of California, Berkley published in last week's
journal the results of years of research into using silicon as thermoelectrics. Their results show that silicon can be a viable thermoelectric.
The key is in the preparation. The researchers prepared thin nanowires of silicon. When these wires are exposed to a temperature difference, they generate electricity. Standard silicon is a poor thermoelectric, but according to Dr. Yang, "the performance of the nanowires is already comparable to the best existing thermoelectric material."
A good thermoelectric needs to have two key properties -- good electrical conduction, and poor heat conduction. Silicon typically conducts both very well, but by producing 50 nm nanowires, the heat conduction of silicon is reduced to one hundreth of its normal levels, while electrical conduction remains unchanged. The material is comparable to commercial thermoelectrics.
Two possible uses of the technology are to generate electricity from waste heat of car engines. Current thermoelectrics are too expensive and large to make this a practical possibility. Nanowire silicon layers, though could provide a means to recapture some of the energy lost to heat during the conversion to mechanical energy in a car engine. This extra savings could be stored in batteries, to give next generation electric vehicles, such as
the Chevrolet Volt
, even better efficiency.
It could also find a home in solar power cells. By coupling it with traditional photoelectric cells, much higher efficiencies could possibly be reached. Yet another application is to put the materials in computers to provide energy savings, which would be particularly valuable to mobile computing. Further, it could be used in refrigeration applications, as well.
Much work needs to be done before the process is perfected. The physics behind why nanowires of silicon lose their heat conduction is not understood, which stands in the way of refining the efficiency of this class of devices. Further creating a thermoelectric on the macroscopic scale, by creating a network of nanowires, has yet to be accomplished. Still, the discovery of these properties in silicon promise a way to eventually use replace current less ideal thermoelectrics with an abundant material with a large processing infrastructure.
This article is over a month old, voting and posting comments is disabled
1/21/2008 12:37:17 PM
So, could I overclock my processor and power my house from it?
1/22/2008 12:21:49 AM
wouldn't work. In a perfect environment you can only get back as much energy as you put in, and assuming your computer used some of that energy for computation purposes you'd get back less energy than you put in. But if you were to loop the generated power back into your computer you're overall power consumption could be cut drastically.
1/22/2008 1:27:10 AM
Hmm, I somehow was thinking about the Prescott whilst reading you're post...
1/23/2008 1:42:22 AM
Think of it as capturing energy from a lightbulb much like a solar panel, but instead your capturing the heat instead of the light rays.
Of course it wont be 100% efficient, but even if it reclaimed 10-20% of the energy excerted from a refridgerator coil, that's 10-20% energy savings.
It could also extend into the automotive industry to replace alternators with thermoelectric generators that run inline with the coolant, reducing the lost horsepower from an alternator.
"Death Is Very Likely The Single Best Invention Of Life" -- Steve Jobs
GM Adds Wiggle Room to 2010 Volt Deadline
January 4, 2008, 11:18 AM
Promise of Thermoelectric Materials on the Rebound
November 27, 2007, 2:32 PM
Sharp Readying Thin Solar Cell Output For 2008
November 4, 2007, 10:58 AM
NSA Leaker May be Killed in Drone Strike Says Ron Paul
June 17, 2013, 11:18 AM
Airbus A350 XWB "MSN1" Has Successful First Flight
June 17, 2013, 11:02 AM
Study: Gamers Have Better Visual, Decision-Making Skills Than Non-Gamers
June 12, 2013, 11:26 AM
Airbus A350 XWB to Take First Flight Friday, Looks to Challenge Boeing Dreamliner
June 11, 2013, 8:20 PM
Berkeley Lab Tests Artificial Photosynthesis with New Microfluidic Test-Bed
June 11, 2013, 11:41 AM
iRobot Corp. to Release "Ava 500" Telepresence Robot for Remote Workers
June 10, 2013, 12:02 PM
Most Popular Articles
Microsoft Xbox One: More Expensive, More DRM, and Slower Than PS4
June 11, 2013, 11:07 AM
GigaHertz Wars 2.0? AMD Releases World's First 5.0 GHz FX Processor
June 11, 2013, 3:16 PM
Xbox Chief: If You Can't Get Online, Don't Buy an Xbox One
June 12, 2013, 9:57 AM
Source: Don't Worry, NSA Spies on "99 Percent" of Americans' Locations, Call Records
June 14, 2013, 3:57 PM
Former Palm CEO: Selling Palm to HP was a Waste
June 12, 2013, 10:19 AM
Latest Blog Posts
Lumosity: Does it Work?
May 22, 2013, 8:20 PM
Quick Note: Sony "Teases" PS4 Ahead of Xbox Reveal in New Video
May 20, 2013, 12:33 PM
Nokia Introduces Instagram-Like App of Its Own to Help Lumia Sales
May 20, 2013, 7:10 AM
Parents of Pre-Teen Drivers Commonly Practice Distracted Driving Says Study
May 9, 2013, 7:16 AM
Apple's iOS 7 Running Into Internal Delays Due to Massive Overhaul
May 1, 2013, 4:26 PM
More Blog Posts
Copyright 2013 DailyTech LLC. -
Terms, Conditions & Privacy Information